Effect of Using Hydroxy Propyl Methyl Cellulose With Extract of Royal Oil (Lepidium sativum) in Reducing Oil Absorption and Quality of Fried Common Carp Fish Fillet (Cyprinus carpio(

Subject Areas : Microbiology

Z. Latifi ¹ , z. Ghafuri ² , Sh. Manochehri ³ , S. Khaki Arani ⁴ , M. Daneshniya ⁵ , L. Roozbeh Nasiraie ⁶ , S. Jafarian ⁷

1 - Young Researchers and elite Club, Sari Branch, Islamic Azad University, Mazandaran, Iran.
2 - Ph.D. Student of Hygiene and Food Quality Control Faculty of Veterinary Medicine, Ahvaz Branch, Shahid Chamran University, Khuzestan, Iran.
3 - MSc Graduate of the Department of Food Science and Technology, Noor Branch, Islamic Azad University, Mazandaran, Iran.
4 - MSc Student of the Department of Food Science and Technology, Varamin Branch, Islamic Azad University, Tehran, Iran.
5 - Young Researchers and Elite Club, Qazvin Branch, Islamic Azad University, Qazvin, Iran.
6 - Assistant Professor, Department of Food Science and Technology, Noor Branch, Islamic Azad University, Mazandaran, Iran.
7 - Assistant Professor, Department of Food Science and Technology, Noor Branch, Islamic Azad University, Mazandaran, Iran.

Received: 2021-06-03 Accepted : 2021-06-03 Published : 2021-06-22

Keywords: fried fish, Hydroxy Propyl Methyl Cellulos, Lepidium sativum extract, oil absorption,

Abstract :

Introduction: In recent years due to the health consumers are attracted to meat products with decreased levels of fat, cholesterol and energy value. Therefore, in the present study, the feasibility of producing superfine fried fish using hydroxy propyl methyl cellulose coated and Lepidium sativum extract was studied. Materials and Methods: Control samples (without coated), treatment 2: hydroxy propyl methyl cellulose, treatment 3: Hydroxy propyl methyl cellulose with Lepidium sativum extract of 500 ppm, treatment 4: hydroxy propyl methyl cellulose with  Lepidium sativum extract of  1000 ppm and treatment 5: hydroxy propyl methyl cellulose with Lepidium sativum extract of  2000 ppm were prepared and the oil absorption, moisture content, peroxide value, thiobarbituric acid and Sensory analysis of fried fish produced were evaluated. Results: The results of physicochemical test showed that hydroxy propyl methyl cellulose with Lepidium sativum extract increased the moisture content and reduced the absorption of oil compared to the control treatment, and was more effective to delay lipid oxidation in fried fish fillet by decreasing peroxide and thiobarbituric values. The best results in relation to these parameters were observed in treatment 5 and then in treatment 4. Sensory score of treatment 4 was higher than the sensory rating of treatment 5. Conclusion: The results of this study indicated that hydroxypropylmethyl cellulose and 1000 ppm concentration of Royal extract can enhance the nutritional value of fish fillet by reducing the oil absorbtion and intreasing the moisture content of fried fish.

References:

Adedeji, A. A. & Ngadi, M. (2011). Porosity determination of deep‐fat‐fried coatings using pycnometer (Fried batter porosity determination by pycnometer). International Journal of Food Science & Technology, 46(6),1266-1275.

Adedeji, A. A., Ngadi, M. O. & Raghavan, G. S. (2009). Kinetics of mass transfer in microwave precooked and deep-fat fried chicken nuggets. Journal of Food Engineering, 91(1),146-153.

Ahmadi, SH. & Aryan, P. (2017). Investigation of Antioxidant Properties of Royal Extract. First National Conference on New Technologies in Iranian Food and Tourism Sciences and Tourism, Babolsar, Mazandaran Province - Applied Science and Technology Center Borna Technology Research Foundation - Sari and Gorgan University of Agriculture and Natural Resources - Shahid Bahonar University of Kerman. [In Persian]

Akdeniz, N., Sahin, S. & Sumnu, G. (2006). Functionality of batters containing different gums for deep-fat frying of carrot slices. Journal of Food Engineering, 75(4), 522-526.

Alipore, M., Kashani Nezhad, M., Maghsudlo, Y. & Jafari, M. (2009). Effect of carrageenan, oiltemperature and frying time on oil absorption in fried potato products. Iranian Food Sci and Technology Research Journal, 5(1), 7-21. [In persian]

Amboon, W., Tulyathan, V. & Tattiyakul, J. (2012). Effect of hydroxypropyl methylcellulose on rheological properties, coating pickup, and oil content of rice flour-based batters. Food and Bioprocess Technology, 5(2), 601-608.

Ammar, E. D., Walter, A. J. & Hall, D. G. (2013). New excised-leaf assay method to test inoculativity of Asian citrus psyllid (Hemiptera: Psyllidae) with Candidatus Liberibacter asiaticus associated with citrus huanglongbing disease. Journal of Economic Entomology,106(1), 25-35.

Ananth, A. & Rajan, S. (2015). In-vitro antioxidant activity of Datura stramonium L. leaves. Advances in Applied Science Research, 6, 147-151.

Anon. (2004). Vegetable oils and fats. Direct measurement of thiobarbituric acid number. Iranian Institute of Standards and Industrial Research, Standard No. 10494.

AOAC. (2000). Official methods of analysis. 17ed. Association of Official analytical Chemists, Washington, DC.

AOCS. (2009). Official Methods and recommended practices of the American Oil Chemist’s Society. AOCS Press. Champaign. I L.

Asadi Farsani, H., Kordjazi, M., Shabanpour, B., Ojagh, S. M. & Jamshidi A. (2018). The Effect of Antioxidant Properties of Brown Algae (Iyengaria Stellata) Extract on the Shelf-life and Sensory Properties of Rainbow Trout (Oncorhynchus Mykiss)Fillet Nugget during Frozen Storage (-18 °C). Research and Innovation in Food Science and Technology, 7, 2. [In persian]

Atarés, L., Pérez-Masiá, R. & Chiralt, A. (2011).The role of some antioxidants in the hpmc film properties and lipid protection in coated toasted almonds. Journal of Food Engineering,104, 649-656.

Bahrami, S., Razi Jalali, M. H., Ramezani, Z., Pourmehdi Boroujeni, M. & Toeimepour, F. (2016). In vitro scolicidal effect of Lepidium sativum essential oil. Journal of Ardabil University of Medical Sciences, 15(4), 395-403. [In persian]

Biswas, A. K., Chatli, M. K. & Sahoo, J. (2012). Antioxidant potential of curry (Murraya koenigii L.) and mint (Mentha spicata) leaf extracts and their effect on colour and oxidative stability of raw ground pork meat during refrigeration storage. Food Chemistry, 133(2), 467-472.

Blois, R. (1958). Chemical structure of anthocyanins in Anthocyanins as Food Colors. J. Pericles Markakis, Academic Press Inc., New York. 1-38.

Chen, S. D., Chen, H. H., Chao, Y. C. & Lin, R. S. (2009). Effect of batter formula on qualities of deep-fat and microwave fried fish nuggets. Journal of Food Engineering, 95(2), 359-364.

 

Dana, D. & Saguy, I. S. (2006). Mechanism of oil uptake during deep-fat frying and the surfactant effect-theory and myth. Advances in Colloid and Interface Science, 128, 267-272.

Dziezak, J. D. (1991). A focus on gums. Food Technology’s Special Report.

Esmaeilzadeh Kenari, R., Mohsenzadeh, F. & Amiri, Z. (2014). Antioxidant activity and total phenolic compounds of Dezful sesame cake extracts obtained by classical and ultrasound-assisted extraction methods, Food Science & Nutriation. [In persian]

Farhoosh, R. & Esmaeilzadeh Kenari, R. (2009). Anti‐rancidity effects of sesame and rice bran oils on canola oil during deep frying. Journal of the American Oil Chemists' Society, 86(6), 539-544. [In persian]

Garma Khani Mirzaei, H., Maghsudlou, Y. & Kashani Nejad, M. (2009). Effect of hydrocolloids on oil absorption and qualitative properties of half-fried potato slices. Journal of Agricultural Science and Natural Resources.Vol. XVI.

Ghidurus, M. I., Turtoi, M., Boskou, G., Niculita, P. E. & Stan, V. (2010). Nutritional and health aspects related to frying (I). Romanian Biotechnological Letters, 15(6), 5675-5682.

Goli Movahed, Gh. & Mehraban Sang Atash, M. (2020). Comparison of antioxidant and antidepressant properties of edible methanolic extracts of edible leaves. Journal of Medicinal Plants. Eighth year, first course,Twenty-ninth machine gun number. [In persian]

Gorgij, A., Shafafi Zanorian, Sh. & Elhami, A. (2014). The effect of frying temperature and pectin coverage on oil content and moisture content in shark fillet. The first national conference on agriculture and sustainable natural resources, Tehran, Mehr Arvand Institute of Higher Education, Promotion Group of Environmental Lovers and the Association for the Protection of nature of Iran. [In persian]

Haghshenas, M., Hosseini, H., Nayebzadeh, K., Rashedi, H. R. & Rahmatzadeh, B. (2013). Effect of β-glucan and carboxymethyl cellulose on sensory and physical properties of processed shrimp nuggets. Iranian Journal of Nutrition Sciences & Food Technology, 8(3), 65-72. [In persian]

Haliloǧlu, H. İ., Bayır, A., Sirkecioǧlu, A. N., Aras, N. M. & Atamanalp, M. (2004). Comparison of fatty acid composition in some tissues of rainbow trout (Oncorhynchus mykiss) living in seawater and freshwater. Food Chemistry, 86(1), 9-55.

Heidary, A. K, Anjaneyulu, A. S. R, Gadekar, Y. P, Singh, R. P. & Pragati, H. (2013). Effect of full-fat soy paste and textured soy granules on quality and shelf-life of goat meat nuggets in frozen storage. Journal of Meat Science, 80, 607-614. [In persian]

Hojjatoleslamy, M., Heidary Soreshjani, B., Molavi, H., Hemmatzade Dastgerdi, S. & Shariaty, M. A. (2013). Producing Low Fat Chicken Nugget Through Coating by Gellan Gum. International Journal of Farming and Allied Sciences, 2(20), 785-789. [In persian]

Hosseini, M. H., Razavi, S. H. & Mousavi, M. A. (2009). Antimicrobial, physical and mechanical properties of chitosan-based films incorporated with thyme, ciove and cinnamon essential oils. Journal Food Process. Preserv. In Press. [In persian]

Jamshidi, A. & Shabanpour, B. (2013). Quality Characteristics of Fried Rainbow Trout (Oncorhynchus mykiss) Fillets Coated with Different Hydrocolloids Edible Films. World Journal of Fish and Marine Sciences, 5(4), 398-404. [In persian]

Jeon, Y. K., Kamil, V. A. & Shahidi, F. (2002). Chitosan as an Edible Invisible film for Quality preservation of Herring and Atlantic cod.  Journal of Agricultural and Food Chemistry, 50, 5167-5178.

Jimenez, L., Ferrer, J. L. & Paniego, L. M. (1989). Rheology, composition and sensory properties of pulped tomatoes. Journal of Food Engineering, 9(2), 119-128

Kim, J., Choi, I., Shin, W. K. & Kim, Y. (2015). Effects of HPMC (Hydroxypropyl methylcellulose) on oil uptake and texture of gluten-free soy donut. LWT-Food Science and Technology, 62(1), 620-627.

Kostaki, M., Giatrakou, V., Savvaidis, I. N. & Kontominas, M. G. (2009). Combined effect of MAP and thyme essential oil on the microbiological, chemical and sensory attributes of organically aquacultured sea bass (Dicentrarchus labrax) fillets. Food Microbiology, 26(5), 475-482.

Maskat, M. Y., Yip, H. H., Mahali, H. M. (2005). The performance of a methyl cellulose‐treated coating during the frying of a poultry product. International Journal of Food Science & Technology, 8, 811-816.

Medina, I., Aubourg, S. P. & Martín, R. P. (1995). Composition of phospholipids of white muscle of six tuna species. Lipids, 30(12), 1127-1135.

Mellema, M. (2003). Mechanism and reduction of fat uptake in deep-fat fried foods. Trends in Food Science & Technology, 14(9), 364-373.

Nadji, H., Diouf, P. N., Benaboura, A., Bedard, Y., Riedl, B. & Stevanovic, T. (2009) Comparative study of lignins isolated from Alfa grass (Stipa tenacissima L.). Bioresource Technology, 100(14), 3585-3592.

Nazan turhan,  K. & Sahbaz, F. (2004). Water vapor permeability, tensile properties and solubility of methylcellulose-based edible films. Journal of Food Engineering, 61, 459–466.

Ojagh, S. M., Rahmanifarah, K., Izadi, S., & Shabanpour, B. (2016). Effect of hydrocolloid coatings on reduction of oil absorption and quality parameters of fried shrimp. Iranian Journal of Food Science and Technology, 13(61), 185-194.

Ojagh, S. M., Rezaei, M., Razavi, S. H. & Hosseini, S. M. (2010). Effect of chitosan coatings enriched with cinnamon oil on the quality of refrigerated rainbow trout. Food Chemistry, (1),193-198.

Ozyurt, G., Kuley, E., Ozkűtűk, S. & Ozogul,  F. (2009). Sensory, microbiological and  chemical assessment of the freshness of red mullet (Mullus barbutus) and goldband  goatfish (Upeneus moluccensis) during storage in ice. Food Chemistry, 114, 505-510.

Pacheco‐Aguilar, R., Lugo‐Sánchez, M. E. & Robles‐Burgueño, M. R. (2000). Postmortem biochemical and functional characteristic of Monterey sardine muscle stored at 0 C. Journal of Food Science, 65(1), 40-47.

Parimala, K. R. & Sudha, M. L. (2012). Effect of hydrocolloids on the rheological, microscopic, mass transfer characteristics during frying and quality characteristics of puri. Food Hydrocolloids, 27(1), 191-200.

Pires, C., Ramos, C., Teixeira, B., Batista, I. & Nunes, M. L. A. M. (2013). Hake proteins edible films incorporated with essential oils: physical, mechanical, antioxidant and antibacterial properties Food Hydrocolloid, 30, 224-31.

Razavi Shirazi, H. (2006). Marine Technology. Publishing House of Mehr. 222. [In persian]

Rimac-Brnčić, S., Lelas, V., Rade, D. & Šimundić, B. (2004). Decreasing of oil absorption in potato strips during deep fat frying. Journal of Food Engineering, 64(2), 237-241.

Shabanpoor, B., Zolfaghari, M., FalahZadeh, S. & Alipoor, G. H. (2012). Effect of extract of Zararia multiflora boiss. on shelf-life of salted vacuum packaged rainbow trout fillet (Oncorhynchus mykiss) in refrigerator conditions: microbial, chemical and sensory attributes assessments. Iranian Journal of Food Science and Technology (JFST), 8 (33), 1-11. [In persian]

Sidewell, G. G., Salwin, H., Benca, M. & Mitchel, J. H. (1954). The use of thiobarbituric acid as a measure of fat oxidation. Journal of the American Oil Chemists’ Society, 31(12), 603-606.

Sonboli, A., Esmaeili, M. A., Gholipour, A., & Kanani, M. R. (2010). Composition, cytotoxicity and antioxidant activity of the essential oil of Dracocephalum surmandinum from Iran. Natural Product Communications, 5(2), 1934578X1000500234. [In persian]

Suárez, R. B., Campanone, L. A., Garcia, M. A. & Zaritzky, N. E. (2008). Comparison of the deep frying process in coated and uncoated dough systems. Journal of Food Engineering, 84(3), 383-393.

Usawakesmanee, W. S., Chinnan, M., Wuttijumnong, P., Jangchud, A. & Raksakulthai, N. (2008). Effect of edible coating ingredients incorporated into predusting mix on moisture content, fat content and consumer acceptability of fried breaded product. Songklanakarin Journal of Science and Technology, 30(Suppl 1), 25-34.

Varela, P. & Fiszman, S. M. (2011). Hydrocolloids in fried foods. A review. Food Hydrocolloids, 25(8), 1801-1812.

Yanar, Y. (2007). Quality changes of hot smoked catfish (Clarias gariepinus) during refrigerated storage. Journal of Muscle Foods, 18(4), 391-400.

Zargiri, A. S. (2000). Medicinal plants. Tehran University Press, Tehran, Iran. 2, 554-558. [In persian]

Zhao, P. & Boosted Lasso, B. Y. (2004). Technical Report, Statistics Department, UC Berkeley. .