Preparation Smart pH Biodegradable Film based on Potato starch/Coleus scutellarioides Anthocyanin Extract /Nano-Zinc Oxide for Monitoring Chicken Fillets

Subject Areas : Journal of Chemical Health Risks

Nima Abdoli Kamali ¹ , Shahriyar Sheykhi ² , Tahereh Sadeghi ³ , Naeimeh Sheykholeslami ⁴ , Neda Fallah ⁵ , Kimia Ghaemmaghami ⁶

1 - Food Health and safety ,Faculty of Health, Qazvin University of Medical Science
2 - Department of Food Science and Technology, Faculty of Agriculture, University of Tabriz, Tabriz P.O. Box 51666-16471, Iran
3 - Department of Food Science and Technology, Science and Research Branch, Islamic Azad University, Tehran, Iran
4 - Department of Food Hygiene, Faculty of Veterinary Medicine, Tabriz Medical Sciences, Islamic Azad University, Tabriz, Iran
5 - Department of Food Science and Technology, Najafabad Branch, Islamic Azad University, Najafabad, Isfahan, Iran. Department of Food Science and Technology, Qom Branch, Islamic Azad University, Qom, Iran
6 - Department of Food Sciences and Technology, Faculty of Pharmacy, Tehran Medical Sciences, Islamic Azad University, Tehran, Iran

Received: 2024-08-25 Accepted : 2024-10-13 Published : 2024-09-24

Keywords: Barrier properties, Bionanocomposite film, Freshness indicator, Mechanical characteristics, Smart packaging,

Abstract :

The purpose of the presentation investigation was to fabricate an intelligent edible film based on potato starch/Coleus scutellarioides anthocyanin extract (CSAE)/nano-ZnO. Then the edible film was investigated to monitor the chicken fillets. The active film was made by casting the potato starch/(CSAE)/nano-ZnO with glycerol/sorbitol (40 w/w%) on casting plates. CSAE was added into edible films (7, 15 and, 30 ml), and the films based on potato starch/(CSAE)/nano-ZnO characteristics, such as mechanical, color, and barrier behaviors were investigated. The active films with different concentrations of 7, 15 and, 30 ml of CSAE represented significantly (p<0.05) lower water vapor permeability (WVP) than the pure biofilm with respective values of 2.66, 2.4 and 1.43×10ٰٖ¹¹(gmsˉ¹Paˉ¹). The tensile strength of the intelligent films significantly decreased (p<0.05) from 192.51 to 151.33 MPa by the adding 30 ml of CSAE into the film. Based on the results, the L* index was significantly higher (p<0.05) in the film containing 30 ml of CSAE. The lowest a* factor was obtained in the film without extract. At the end of the preservation time, the TVB-N value of chicken fillets reached 38.25 mg N/100, and the mentioned index significantly increased (p<0.05), the color characteristics of the intelligent edible films also changed. The color of the active films based on potato starch/nano-ZnO/CSAE was purple, but the a* index significantly decreased. Therefore, the biodegradable film based on potato starch/nano-ZnO/CSAE can be utilized as a biocompatible indicator of chicken fillets.

References:

1. Vedove T.M.A.R.D., Maniglia B.C., Tadini C.C., 2021. Production of sustainable smart packaging based on cassava starch and anthocyanin by an extrusion process. Journal of Food Engineering. 289, 110274.
2. Said N.S., Howell N.K., Sarbon N.M., 2023. A Review on Potential Use of Gelatin-based Film as Active and Smart Biodegradable Films for Food Packaging Application. Food Reviews International. 39(2), 1063-1085.
3. Kuswandi B., Seftyani M., Pratoko D.K., 2024. Edible colorimetric label based on immobilized purple sweet potato anthocyanins onto edible film for packaged mushrooms freshness monitoring. Journal of Food Science and Technology. 61(2),1811-1822.
4. Tarlak F., Pérez-Rodríguez F., 2021. Development and validation of a one-step modelling approach for the determination of chicken meat shelf-life based on the growth kinetics of Pseudomonas spp. Food Science and Technology International. 28(8), 672-682.
5. Cvek M., Paul U.C., Zia J., Mancini G., Sedlarik V., Athanassiou A., 2022. Biodegradable Films of PLA/PPC and Curcumin as Packaging Materials and Smart Indicators of Food Spoilage. ACS Applied Materials & Interfaces. 14(12), 14654-14667.
6. Gasti T., Dixit S., D'Souza O. J., Hiremani V.D., Vootla S. K., Masti S.P., Chougale R. B., Malabadi R. B., 2021. Smart biodegradable films based on chitosan/methylcellulose containing Phyllanthus reticulatus anthocyanin for monitoring the freshness of fish fillet. International Journal of Biological Macromolecules. 187, 451-461.
7. Karaca I.M., Haskaraca G., Ayhan Z., Gültekin E., 2023. Development of real time-pH sensitive intelligent indicators for monitoring chicken breast freshness/spoilage using real packaging practices. Food Research International. 173, 113261.
8. Ekramian S., Abbaspour H., Roudi B., Amjad L., Mohammadi Nafchi A., 2021. An experimental study on characteristics of sago starch film treated with methanol extract from Artemisia sieberi Besser. Journal of Food Measurement and Characterization. 15(4), 3298-3306.
9. Alappat B., Alappat J., 2020. Anthocyanin Pigments: Beyond Aesthetics. Molecules. 25(23), 5500.
10. Nobari A., Marvizadeh M.M., Sadeghi T., Rezaei-savadkouhi N., Mohammadi Nafchi A., 2022. Flavonoid and Anthocyanin Pigments Characterization of Pistachio Nut (Pistacia vera) as a Function of Cultivar. Journal of Nuts. 13(4), 313-322.
11. Zhu B., Zhong Y., Wang D., Deng Y., 2023. Active and Intelligent Biodegradable Packaging Based on Anthocyanins for Preservation and Monitoring Rich Protein Foods. Foods. 12(24), 4491. https://doi.org/10.3390/foods12244491.
12. Wang F., Xie C., Tang H., Li H., Hou J., Zhang R., Liu Y., Jiang L., 2023. Intelligent packaging based on chitosan/fucoidan incorporated with coleus grass (Plectranthus scutellarioides) leaves anthocyanins and its application in monitoring the spoilage of salmon (Salmo salar L.). International Journal of Biological Macromolecules. 252, 126423.
13. Al-Mafarjy S.S., Suardi N., Ahmed N.M., Kernain D., Hisham Alkatib H., Dheyab M.A., 2024. Green synthesis of gold nanoparticles from Coleus scutellarioides (L.) Benth leaves and assessment of anticancer and antioxidant properties. Inorganic Chemistry Communications. 161, 112052.
14. Jafari R., Zandi M., Ganjloo A., 2023. Characterization of Alginate-Gelatin Edible Film Containing Anise (Pimpinella anisum L.) Essential Oil. Journal of Polymers and the Environment. 31(4), 1568-1583.
15. Duguma H.T., 2022. Potential applications and limitations of edible coatings for maintaining tomato quality and shelf life. International Journal of Food Science & Technology. 57(3), 1353-1366.
16. Chavoshi N., Marvizadeh M.M., Fallah N., Rezaei-savadkouhi N., Mohammadi Nafchi A., 2023. Application of Novel Nano-biopackaging Based on Cassava Starch/Bovine Gelatin / Titanium oxide nanoparticle/Fennel Essential Oil to Improve Quality of the Raw Fresh Pistachio. Journal of Nuts. 14(1), 19-31.
17. Marvizadeh M.M., Mohammadi Nafchi A., Jokar M., 2014. Preparation and Characterization of Novel Bionanocomposite Based on Tapioca Starch/Gelatin/Nanorod-rich ZnO: Towards Finding Antimicrobial Coating for Nuts. Journal of Nuts. 05 (02), 39-47.
18. Luchese C.L., Uranga J., Spada J.C., Tessaro I.C., de la Caba K., 2018. Valorisation of blueberry waste and use of compression to manufacture sustainable starch films with enhanced properties. International Journal of Biological Macromolecules. 115, 955-960.
19. Marvizadeh M., Mohammadi Nafchi A., Jokar M., 2016. Obtaining and Characterization of Bionanocomposite Film Based on Tapioca Starch/Bovine Gelatin/Nanorod Zinc Oxide. 2nd Congress on Food Structure Design. Akdeniz university, 160
20. Abdorreza M.N., Cheng L.H., Karim A.A., 2011. Effects of plasticizers on thermal properties and heat sealability of sago starch films. Food Hydrocolloids. 25(1), 56-60.
21. ASTM D (2018), 2018. standard test method for tensile properties of thin plastic sheeting. Annual Book of American Standard Testing Methods; American Society for Testing and Materials West Conshohocken, PA, USA, 8, , 182-190.
22. ASTM E, 2005. Annual Book of ASTM Standards, ASTM, Philadelphia, PA.
23. Mirzapour-Kouhdasht A., Moosavi-Nasab M., 2020. Shelf-life extension of whole shrimp using an active coating containing fish skin gelatin hydrolysates produced by a natural protease. Food Science & Nutrition. 8(1), 214-223.
24. Fallah N., Marvizadeh M.M., Jahangiri R., Zeinalzadeh A., Mohammadi Nafchi A., 2022. High-Barrier and Light–protective Bionanocomposite Film Based on Rye Starch/nanorod-ZnO for Food Packaging Applications. Journal of Chemical Health Risks. 13(2), 299-304.
25. Fallah N., Nabeghvatan N., Sadeghi T., Etemadi Razlighi A., Marvizadeh M.M., Mohammadi Nafchi A., 2023. Antimicrobial and Hydrophilic Behavior of Soluble Soy Polysaccharide Starch/Cold Water Fish Gelatin Films Incorporated with Nano-Titanium Dioxide. Journal of Chemical Health Risks. 14(2), 291-298.
26. Hematian F., Baghaei H., Mohammadi Nafchi A., Bolandi M., 2023. Preparation and characterization of an intelligent film based on fish gelatin and Coleus scutellarioides anthocyanin to monitor the freshness of rainbow trout fish fillet. Food Science & Nutrition. 11(1), 379-389.
27. Prietto L., Mirapalhete T.C., Pinto V.Z., Hoffmann J.F., Vanier N.L., Lim L.T., Guerra Dias A.R., da Rosa Zavareze E., 2017. pH-sensitive films containing anthocyanins extracted from black bean seed coat and red cabbage. LWT, 80, 492-500.
28. Musso Y. S., Salgado P. R., Mauri A. N., 2019. Smart gelatin films prepared using red cabbage (Brassica oleracea L.) extracts as solvent. Food Hydrocolloids. 89, 674-681.
29. Marvizadeh M.M., Tajik A., Moosavian V., Oladzadabbasabadi N., Mohammadi Nafchi A., 2021. Fabrication of Cassava Starch/Mentha piperita Essential Oil Biodegradable Film with Enhanced Antibacterial Properties. Journal of Chemical Health Risks. 11(1), 23-29.
30. Hematian F., Baghaie H., Mohammadi Nafchi A., Bolandi M., 2022. The effects of Coleus scutellarioides extract on physicochemical and antioxidant properties of fish gelatin active films. Journal of Food and Bioprocess Engineering. 5(1), 9-15.
31. Azlim N.A., Mohammadi Nafchi A., Oladzadabbasabadi N., Ariffin F., Ghalambor P., Jafarzadeh S., Al-Hassan A.A., 2022. Fabrication and characterization of a pH-sensitive intelligent film incorporating dragon fruit skin extract. Food Science & Nutrition. 10(2), 597-608.
32. Sun G., Chi W., Zhang C., Xu S., Li J., Wang L., 2019. Developing a green film with pH-sensitivity and antioxidant activity based on к-carrageenan and hydroxypropyl methylcellulose incorporating Prunus maackii juice. Food Hydrocolloids. 94, 345-353.
33. Marvizadeh M.M., Oladzadabbasabadi N., Mohammadi Nafchi A., Jokar M., 2017. Preparation and characterization of bionanocomposite film based on tapioca starch/bovine gelatin/nanorod zinc oxide. International Journal of Biological Macromolecules. 99, 1-7.
34. Koosha M., Hamedi S., 2019. Intelligent Chitosan/PVA nanocomposite films containing black carrot anthocyanin and bentonite nanoclays with improved mechanical, thermal and antibacterial properties. Progress in Organic Coatings. 127, 338-347.
35. Zhang J., Zou X., Zhai X., Huang X., Jiang C., Holmes M., 2019. Preparation of an intelligent pH film based on biodegradable polymers and roselle anthocyanins for monitoring pork freshness. Food Chemistry. 272, 306-312.
36. Sun W., Liu Y., Jia L., Saldaña M. D. A., Dong T., Jin Y., Sun W., 2021. A smart nanofibre sensor based on anthocyanin/poly-l-lactic acid for mutton freshness monitoring. International Journal of Food Science & Technology. 56(1), 342-351.
37. Qin Y., Xu F., Yuan L., Hu H., Yao X., Liu J., 2020. Comparison of the physical and functional properties of starch/polyvinyl alcohol films containing anthocyanins and/or betacyanins. International Journal of Biological Macromolecules. 163, 898-909.