Effect of Konjac Gum as a Fat Replacer on Rheological and Sensory Properties of Low Fat Mayonnaise

Subject Areas : Microbiology

M. Jarangi ¹ , F. Abdolmaleki ² , B. Ghiassi Tarzi ³

1 - M. Sc. Student of the Department of Food Science & Technology, Science and Research Branch, Islamic Azad University, Tehran, Iran.
2 - Assisstant Professor of the Department of Food Science & Technology, Faculty of Industrial and Mechanical Engineering, Qazvin Branch, Islamic Azad University, Qazvin, Iran.
3 - Associate Professor of the Department of Food Science & Technology, Science and Research Branch, Islamic Azad University, Tehran, Iran.

Received: 2021-12-25 Accepted : 2021-12-25 Published : 2021-12-22

Keywords: Fat Substitutes, Konjac Gum, Low-Fat Mayonnaise, Rheology, Sensory Properties,

Abstract :

Introduction: Considering the increasing consumption of fat-rich foods over the last decades and its relationship with prevalence of cardiovascular diseases, development of low-fat food formulations is of special importance. Hydrocolloids such as gums have great potential for imitating the role of fat in foodstuff. The aim of the present study was to explore the capability of konjac gum to replace the fat in mayonnaise. Materials and Methods: Different concentrations of konjac gum (0.25, 0.5, 0.75 and 1%) were incorporated into the formulation of mayonnaise with 20, 30, 40 and 50% oil reductions, respectively. The static (flow behavior) and dynamic (strain sweep and frequency sweep) rheological properties were measured using a rheometer and sensory chracteristics were evaluated by a 10-member sensory panel. The rheological and sensory properties of low-fat mayonnaise containing different concentrations of konjac gum were compared with each other and low-fat control (30% fat) using a completely randomized design at 95% confidence interval. Results: The results of fitting the rheological data to Power-Law and Herschel-Bulkley models showed that all samples had pseudoplastic behavior. The low-fat samples containing different concentrations of konjac gum had lower flow index and higher consistency index than the control sample. Similarly, the yield stress was enhanced with gum concentration up to 0.5% but decreased after that. The finding of oscillating frequency sweep test showed that all samples had storage modulus larger than loss modulus and loss tangent lower than 1, confirming the viscoelastic characteristics of the samples. Furthermore, the loss tangent steadily decreased with increase in konjac concentration. It was observed that konjac gum had a significantly improving impact on stability index of reduced-fat mayonnaise in a concentration-dependent manner. The results of sensory analysis revealed that konjac gum significantly improved the texture, viscosity and overall acceptability but did not have any significant effect on odor and flavor of low-fat mayonnaise. Conclusion: It is concluded that the low-fat mayonnaise sample containing 0.5% konjac gum was the best formulation in terms of rheological and sensory properties.

References:

 

Alimi, M., Mizani, M., Naderi, G., & Shokoohi, S. (2013). Effect of inulin formulation on the microstructure and viscoelastic properties of low‐fat mayonnaise containing modified starch. Journal of Applied Polymer Science, 130 (2), 801-809.

Amiri, A .S. S. (2011). Extraction of beta-glucan from barley and its use in formulation of mayonnaise sauce, MSc thesis, Gorgan University of Agricultural Sciences and Natural Resources [In Persian].

Amiri, A .S. S., Alami, M. & Rezaei, R. (2011). Feasibility of gum tragacanth and maltodextrin used as a fat replacer in mayonnaise. Electronic Journal of Food Processing and Preseravtion, 2 (3), 1-18 [In Persian].

Amiri, A .S. S., Alami, M. & Arabshahi, S. (2014). The effect of basil seed mucilage as a fat substitute on the physicochemical, rheological, textural and sensory characteristics of low-fat mayonnaise, Journal of Food Research, 24 (2), 249-265 [In Persian].

Akoh, C.C. (1998). Fat replacers. Food technology (Chicago), 52(3), pp.47-53.

Aslanzadeh, M., Mizani, M., Alimi, M. & Gerami, A. (2014). Evaluation of produced dietary fiber from wheat bran as a fat replacer in mayonnaise. Food Technology & Nutrition, 11 (1), 21-31 [In Persian].

Barbosa-Canovas, G. V. & Ma, L. (1995). Rheological characterization of mayonnaise. Part 2: Flow and Viscoelastic Properties at Different Oil and Xanthan Gum Concentrations. Journal of Food Engineering, 25 (3), 40-425.

Behera, S. S. & Ray, R. C. (2017). Nutritional and potential health benefits of konjac glucomannan, a promising polysaccharide of elephant foot yam, Amorphophallus konjac K. Koch: A review. Food Reviews International, 33(1), 22-43.

Chaisawang, M., & Suphantharika, M. (2005). Effects of guar gum and xanthan gum additions on physical and rheological properties of cationic tapioca starch. Carbohydrate polymers, 61 (3), 288-295.

Choonhahirun, A. (2008). Influence of added water and konjac flour as fat replacer on some quality characteristics of celery mayonnaise. AU J T, 11 (3), 154-158.

Depree, J. A. & Savage, G. P. (2001). Physical and flavor stability of mayonnaise. Trends in Food Science & Technology, 12, 157-163.

Heyman, B., Depypere, F., Delbaere, C. & Dewettinck, K. (2010). Effects of non-starch hydrocolloids on the physicochemical properties and stability of a commercial béchamel sauce. Journal of food engineering, 99 (2), 115-120.

Jooyandeh, H., Goudarzi, M., Rostamabadi, H., & Hojjati, M. (2017). Effect of Persian and almond gums as fat replacers on the physicochemical, rheological, and microstructural attributes of low‐fat Iranian White cheese. Food science & nutrition, 5(3), 669-677.

Juszczak, L., Fortuna T. & A. Kosla. (2003). Sensory and Rheological properties of polish commercial Mayonnaise, Food /Nahrung, 47 (4), 232-235

Koocheki, A., Taherian, A. R. & Bostan, A. (2013). Studies on the steady shear flow behavior and functional properties of Lepidium perfoliatum seed gum. Food Research International, 50 (1), 446-456.

Kruk, J., Kaczmarczyk, K., Ptaszek, A., Goik, U. & Ptaszek, P. (2017). The effect of temperature on the colligative properties of food-grade konjac gum in water solutions. Carbohydrate Polymers, 174, 456-463.

Liu, H., Xu, X. & Guo, S. D. (2007). Rheological, texture and sensory properties of low-fat mayonnaise with different fat mimetics. LWT-Food Science and Technology, 40(6), 946-954.

Ma, L., & Barbosa-Cánovas, G. (1995). Rheological characterization of mayonnaise. Part II: Flow and viscoelastic properties at different oil and xanthan gum concentrations. Journal of food engineering, 25 (3), 409-425.

McClements D. J. (2009). Biopolymers in Food Emulsions. Pp. 129-166. In: Kasapis S, Norton IT and Ubbink JB (Eds). Modern Biopolymer Science. Elsevier, London

Mahrooghi, M., Ghods Rohani, M. & Rashidi, H. (2016). The optimization of spreadable process cheese formulation using konjac and xanthan gums. Journal of Research and Innovation in Food Science and Technology, 5 (4), 369-382 [In Persian].

Mandala, I. G., Savvas, T. P. & Kostaropoulos, A. E. (2004). Xanthan and locust bean gum Influence on the rheology and structure of a white model-ssauce. Journal of Food Engineering, 64, 335-342.

Maskan, M. & Göǧüş, F. (2000). Effect of sugar on the rheological properties of sunflower oil–water emulsions. Journal of Food Engineering, 43(3), 173-177.

Mun, S., Kim, Y., Kang, C., Park, K., Shim, J. & Kim, Y. (2009). Development of reduced-fat mayonnaise using 4-GTase-modified rice starch and xanthan gum. International Journal of Biological Macromolecules, (44), 400-407.

Mirzaei, M., Alimi, M. & Shokouhi, S. (2015). Interaction effects of konjac mannan, xanthan, kappa carrageenan and tragacanth gums on rhological properties of ketchup sause. 23th National Congress of Food science and Technology (pp. 1-24). Ghouchan Azad University, Ghouchan, Iran [In Persian].

Nikzade, V., Mazaheri Tehrani, M. & Saadatmand, M. (2012). Optimization of low-cholesterol-low-fat mayonnaise formulation: Effect of using soy milk and some stabilizer by a mixture design approach. Food Hydrocolloid, 28, 344-352

Rao, M. (1999). Rheology of fluid and semisolid foods. Gaithersburg. Maryland: Aspen.

Sahin, H., & Ozdemir, F. (2004). Effect of some hydrocolloids on the rheological properties of different formulated ketchups. Food Hydrocolloids, 18(6), 1015-1022.

Schorsch, C., Garnier, C. & Doublier, J.-L. (1997). Viscoelastic properties of xanthangalactomannan mixtures: comparison of guar gum with locust bean gum. Carbohydrate polymers, 34(3), 165-175.

Sharoba, A., Senge, B., El-Mansy, H., Bahlol, H. E., & Blochwitz, R. (2005). Chemical, sensory and rheological properties of some commercial German and Egyptian tomato ketchups. European Food Research and Technology, 220(2), 142-151.

Shen, R., Luo, S. & Dong, J. (2011). Application of oat dextrine for fat substitute in mayonnaise. Food Chemistry, 126, 65-71.

Steffe, J. F. (1996). Rheological methods in food process engineering: Freeman press.

Su, H. P., Lien, C. P., Lee, T. A. & Ho, J. H. (2010). Development of low-fat mayonnaise containing polysaccharide gums as functional ingredients. Journal of the Science of Food and Agriculture, 90(5), 806-812.

Tabilo-Munizaga G. & Barbosa-Canovas, G.V. (2005). Rheology for food Industry, Journal of Food Engineering, 67, 147156.

Taherian, A. R., Fustier, P. & Ramaswamy, H. S. (2006). Effect of added oil and modified starch on rheological properties, droplet size distribution, opacity and stability of beverage cloud emulsions. Journal of Food Engineering, 77(3), 687-696.

Wang, T., Zhang, M., Fang, Z., Liu, Y. & Gao, Z. (2016). Rheological, textural and flavour properties of yellow mustard sauce as affected by modified starch, xanthan and guar gum. Food and Bioprocess Technology, 9(5), 849-858.

Worrasinchai, S., Suphantharika, M., Pinjai, S. & Jamnong, P. (2006). B-Glucan prepared from spent brewer’s yeast as a fat replacer in mayonnaise. Food Hydrocolloids, 20, 68–78.