Effect of Basil Seed Mucilage Coating on the Oil Absorption and Physical Characteristics of Fried Zucchini Slices

Subject Areas : food science

Fakhreddin Salehi ¹ , Alireza Haseli ² , Amirreza Roustaei ³

1 - Associate Professor of the Department of Food Science and Technology, Bu-Ali Sina University, Hamedan, Iran
2 - Student of the Faculty of Agriculture, Bu-Ali Sina University, Hamedan, Iran
3 - Student of the Faculty of Agriculture, Bu-Ali Sina University, Hamedan, Iran

Received: 2022-12-06 Accepted : 2023-05-26 Published : 2023-10-01

Keywords: Surface Change, Frying Process, Color Indexes, Basil Seed Mucilage,

Abstract :

In this study, the efficiency of Basil seeds mucilage (BSM) as an edible coating (three concentrations of 0.5, 1.0, and 1.5%) and the temperature of frying oil (three concentrations of 155°C, 170°C, and 185°C) on reduces oil absorption and moisture retention of zucchini slices during the frying process were investigated. The color index includes a* (redness), b* (yellowness), L* (lightness), and color change intensity (∆E) was used to determines the appearance changes of fried zucchini slices. The BSM coating treatment reduced the oil absorption of fried zucchini slices by approximately 22.48%. Increasing the BSM concentration from 0.0% to 1.5% significantly decreased the oil absorption of zucchini slices from 8.96% to 6.94% (P<0.05). On the other hand, the moisture content of the samples increased from 83.9% to 86.88% with increasing gum concentration (P<0.05). The lowest ∆E and surface shrinkage (%) values were obtained for zucchini slices treated with 1.5 % BSM and fried at 155°C. By increasing the BSM concentration from 0.0% to 1.5% significantly decreased the percentage change in surface area of fried zucchini slices from 33.13% to 26.41% (P<0.05). The appropriate coating suspension and frying temperature to reduce oil absorption and moisture retention of fried zucchini slices were 0.5% BSM and 155°C, respectively.

References:

Adrah, K., Ananey-Obiri, D. & Tahergorabi, R., (2021). Physicochemical changes of deep-fat-fried chicken drumsticks treated with quercetin-in-edible coating during storage time, Foods, p. 467.

Ali, M.R., Parmar, A., Niedbała, G., Wojciechowski, T., Abou El-Yazied, A., El-Gawad, H.G.A., Nahhas, N.E., Ibrahim, M.F.M. & El-Mogy, M.M., (2021). Improved Shelf-Life and Consumer Acceptance of Fresh-Cut and Fried Potato Strips by an Edible Coating of Garden Cress Seed Mucilage, Foods.

Amini, G., Salehi, F. & Rasouli, M. (2021). Drying kinetics of basil seed mucilage in an infrared dryer: Application of GA-ANN and ANFIS for the prediction of drying time and moisture ratio. Journal of Food Processing and Preservation, 45(3), e15258.

Daraei Garmakhany, A., Mirzaei, H.O., Nejad, M.K. & Maghsudlo, Y. (2008). Study of oil uptake and some quality attributes of potato chips affected by hydrocolloids. European Journal of Lipid Science and Technology, 110(11), 1045-1049.

Han, L., He, Y., Wang, S., Cheng, W., Ma, L., Liu, G., Han, D. & Niu, L. (2021). Effects of methyl cellulose-based coating on physiochemical properties and chemical hazards of Chinese fried dough cake during storage. International Journal of Food Science & Technology, 56(9), 4770-4779.

Jouki, M. & Khazaei, N. (2022). Effects of active batter coatings enriched by quince seed gum and carvacrol microcapsules on oil uptake and quality loss of nugget during frying. Journal of Food Science and Technology, 59(3), 1104-1113.

Karimi, N. & Kenari, R.E. (2016). Functionality of coatings with salep and basil seed gum for deep fried potato strips. Journal of the American Oil Chemists' Society, 93(2), 243-250.

Kurek, M., Repajić, M., Marić, M., Ščetar, M., Trojić, P., Levaj, B. & Galić, K. (2021). The influence of edible coatings and natural antioxidants on fresh-cut potato quality, stability and oil uptake after deep fat frying. Journal of Food Science and Technology, 58, 3073–3085.

Li, Y., Li, Z., Guo, Q., Kong, B., Liu, Q. & Xia, X. (2022). Inhibitory effect of chitosan coating on oil absorption in French fries based on starch structure and morphology stability. International Journal of Biological Macromolecules, 219, 1297-1307.

Maity, T., Bawa, A.S. & Raju, P.S. (2014). Effect of vacuum frying on changes in quality attributes of jackfruit (Artocarpus heterophyllus) bulb slices. International journal of food science, 2014, 1-8.

Naji Tabasi, S. & Mahdian, E. (2017). The investigation of sage seed and persian gum coating effect on oil mass transfer and quality attributes of potato chips. Research and Innovation in Food Science and Technology, 6(2), 171-184.

Ouchon, P.B. & Pyle, D.L. (2004). Studying oil absorption in restructured potato chips. Journal of Food Science, 69(3), FEP115-FEP122.

Salehi, F. (2018). Color changes kinetics during deep fat frying of carrot slice. Heat and Mass Transfer, 54(11), 3421-3426.

Salehi, F. (2020). Effect of coatings made by new hydrocolloids on the oil uptake during deep‐fat frying: A review. Journal of Food Processing and Preservation, 44(11), e14879.

Salehi, F., Haseli, A. & Roustaei, A. (2022a). Coating of zucchini slices with Balangu, Basil, and Wild sage seeds gums to improve the frying properties. European Journal of Lipid Science and Technology, 124(2), 2100120.

Salehi, F., Haseli, A. & Roustaei, A. (2022b). Influence of frying conditions and wild sage seed mucilage coating on the physical properties and oil uptake of zucchini slices during deep-fat frying. Journal of Food Biosciences and Technology, 12(2), 15-22.

Salehi, F., Roustaei, A. & Haseli, A. (2021). Effect of surface coating with seeds mucilages and xanthan gum on oil uptake and physical properties of fried potato strips. Food science & nutrition, 9(11), 6245-6251.

Satorabi, M., Salehi, F. & Rasouli, M. (2021). The influence of xanthan and balangu seed gums coats on the kinetics of infrared drying of apricot slices: GA-ANN and ANFIS modeling. International Journal of Fruit Science, 21(1), 468-480.

Xie, D., Guo, D., Guo, Z., Hu, X., Luo, S. & Liu, C. (2022). Reduction of oil uptake of fried food by coatings: A review. International Journal of Food Science & Technology, 57(6), 3268-3277.

Yadegari, M., Esmaeilzadeh Kenari, R. & Hashemi, S.J. (2020). Investigation the effect of separate and mutual interactions of Alyssum homolocarpum seed and methylcellulose gums on qualitative properties of fried potato. Journal of Innovation in Food Science and Technology, 11(4), 89-101.