Effect of growth time on ZnO thin films prepared by low temperature chemical bath deposition on PS substrate

Subject Areas : Journal of Nanoanalysis

Reza  Shabannia ¹ (Department of Physics, College of Science, Babol Noshirvani University of Technology, Babol, Iran.)
Nima  Naderi ² (Department of Semiconductors, Materials and Energy Research Center, Karaj, Iran)

Received: 2019-08-15 Accepted : 2019-08-15 Published : 2019-06-01

Keywords: Crystal Structure, Growth Time, Chemical Bath Deposition, Porous Silicon, ZnO Thin Films,

Abstract :

ZnO thin films were successfully synthesized on a porous silicon (PS) substrate by chemical bath deposition method. X-ray diffraction (XRD), field-emission scanning electron microscopy (FESEM), and photoluminescence (PL) analyses were carried out to investigate the effect of growth duration (3, 4, 5, and 6 h) on the optical and structural properties of the aligned ZnO nanorods. The small FWHM and stronger diffraction intensity of growth times of 5 h mean the better crystal quality of ZnO thin films compared to others. The grain size of the ZnO thin films gradually increased with increased the growth time. The FESEM images show that the thickness of ZnO thin films increased with increase of the growth time. Photoluminescence measurements showed that there was a sharp and highly intense UV emission peak when growth time was 5 h. The structural and optical investigations revealed that the ZnO thin films grown on the PS substrate with growth time of 5 h had high structural and optical quality.

References:

 

1. Park J, Shin DS, Kim D-H. Enhancement of light extraction in GaN-based light-emitting diodes by Al2O3-coated ZnO nanorod arrays. Journal of Alloys and Compounds. 2014;611:157-60.

2. Mariappan R, Ponnuswamy V, Suresh P, Ashok N, Jayamurugan P, Chandra Bose A. Influence of film thickness on the properties of sprayed ZnO thin films for gas sensor applications. Superlattices and Microstructures. 2014;71:238-49.

3. Bae SH, Lee SY, Kim HY, Im S. Effects of post-annealing treatment on the light emission properties of ZnO thin films on Si. Optical Materials. 2001;17(1-2):327-30.

4. Inamdar SI, Ganbavle VV, Rajpure KY. ZnO based visible–blind UV photodetector by spray pyrolysis. Superlattices and Microstructures. 2014;76:253-63.

5. Devabharathi V, Palanisamy KL, Meenakshi Sundaram N. Influence of pH on the performance of ZnO nanocrystal based dye sensitized solar cells. Superlattices and Microstructures. 2014;75:99-104.

6. Przeździecka E, Stachowicz M, Chusnutdinow S, Jakieła R, Kozanecki A. Electron beam induced current profiling of the p-ZnO:N/n-GaN heterojunction. Applied Physics Letters. 2015;106(6):062106.

7. Chen H, Ding J, Guo W. Enhanced blue emission from Si/Al2O3/Zn/ZnO multilayer films. Journal of Alloys and Compounds. 2015;620:294-8.

8. Vähä-Nissi M, Pitkänen M, Salo E, Kenttä E, Tanskanen A, Sajavaara T, et al. Antibacterial and barrier properties of oriented polymer films with ZnO thin films applied with atomic layer deposition at low temperatures. Thin Solid Films. 2014;562:331-7.

9. Kaidashev EM, Lorenz M, von Wenckstern H, Rahm A, Semmelhack HC, Han KH, et al. High electron mobility of epitaxial ZnO thin films on c-plane sapphire grown by multistep pulsed-laser deposition. Applied Physics Letters. 2003;82(22):3901-3.

10. Al-Salman HS, Abdullah MJ. RF sputtering enhanced the morphology and photoluminescence of multi-oriented ZnO nanostructure produced by chemical vapor deposition. Journal of Alloys and Compounds. 2013;547:132-7.

[11] E. Makarona, M. Skoulikidou, T. Kyrasta, A. Smyrnakis, A. Zeniou, E. Gogolides, and C. Tsamis, Nanoforest of hydrothermally grown hierarchical ZnO nanowires for a high efficiency dye-sensitized solar cell, Mate. Lett. 142, 211 (2015). doi:10.1016/j.matlet.2014.12.008.

12. Ghosh R, Giri PK, Imakita K, Fujii M. Photoluminescence signature of resonant energy transfer in ZnO coated Si nanocrystals decorated on vertical Si nanowires array. Journal of Alloys and Compounds. 2015;638:419-28.

13. Chu S, Olmedo M, Yang Z, Kong J, Liu J. Electrically pumped ultraviolet ZnO diode lasers on Si. Applied Physics Letters. 2008;93(18):181106.

14. Zhang H, Lv X, Lv C, Jia Z. n-Type porous silicon as an efficient surface enhancement Raman scattering substrate. Optical Engineering. 2012;51(9):099003-1.

15. Chen JY, Sun KW. Growth of vertically aligned ZnO nanorod arrays as antireflection layer on silicon solar cells. Solar Energy Materials and Solar Cells. 2010;94(5):930-4.

16. Polat İ. Effects of Na-doping on the efficiency of ZnO nanorods-based dye sensitized solar cells. Journal of Materials Science: Materials in Electronics. 2014;25(9):3721-6.

17. Kim D-K, Park C-B. Effects of in situ annealing on the properties of Al-doped ZnO thin films deposited by RF magnetron sputtering. Journal of Materials Science: Materials in Electronics. 2014;25(4):1589-95.

18. Liang JH, Lai HY, Chen YJ. Morphology transition of ZnO films with DMZn flow rate in MOCVD process. Applied Surface Science. 2010;256(23):7305-10.

19. Kang SJ, Joung YH. Influence of substrate temperature on the optical and piezoelectric properties of ZnO thin films deposited by rf magnetron sputtering. Applied Surface Science. 2007;253(17):7330-5.

20. Bian JM, Li XM, Gao XD, Yu WD, Chen LD. Deposition and electrical properties of N–In codopedp-type ZnO films by ultrasonic spray pyrolysis. Applied Physics Letters. 2004;84(4):541-3.

21. Shabannia R. Vertically aligned ZnO nanorods on porous silicon substrates: Effect of growth time. Progress in Natural Science: Materials International. 2015;25(2):95-100.

22. Ki Hyun Y, Choi J-W, Lee D-H. Characteristics of ZnO thin films deposited onto Al/Si substrates by r.f. magnetron sputtering. Thin Solid Films. 1997;302(1-2):116-21.

23. Wang C, Zhang P, Yue J, Zhang Y, Zheng L. Effects of annealing and supersonic treatment on the structure and photoluminescence of ZnO films. Physica B: Condensed Matter. 2008;403(13-16):2235-40.

24. Hong R, Huang J, He H, Fan Z, Shao J. Influence of different post-treatments on the structure and optical properties of zinc oxide thin films. Applied Surface Science. 2005;242(3-4):346-52.

25. Lotgering FK. Topotactical reactions with ferrimagnetic oxides having hexagonal crystal structures—I. Journal of Inorganic and Nuclear Chemistry. 1959;9(2):113-23.

26. Sanon G, Rup R, Mansingh A. Growth and characterization of tin oxide films prepared by chemical vapour deposition. Thin Solid Films. 1990;190(2):287-301.

27. Umar A, Karunagaran B, Suh EK, Hahn YB. Structural and optical properties of single-crystalline ZnO nanorods grown on silicon by thermal evaporation. Nanotechnology. 2006;17(16):4072-7.

28. Lin C-C, Chen H-P, Liao H-C, Chen S-Y. Enhanced luminescent and electrical properties of hydrogen-plasma ZnO nanorods grown on wafer-scale flexible substrates. Applied Physics Letters. 2005;86(18):183103.

29. Kwok WM, Djurišić AB, Leung YH, Li D, Tam KH, Phillips DL, et al. Influence of annealing on stimulated emission in ZnO nanorods. Applied Physics Letters. 2006;89(18):183112.