Evaluation of the efficiency of the sono-electrochemical process for the removal of environmental pollutants in aquatic ecosystems (Case study: formaldehyde removal)
amir mohammad farhoodi
1
,
Amirhessam Hassani
2
,
Giti Kashi
3
*
,
amirhossein javid
4
,
Nabiallah Mansouri
5
1 - PhD Student, Department of Environmental Engineering, Science and Research Branch, Islamic Azad University, Tehran, Iran
2 - Department Environmental Pollution, Faculty of Energy and Environment, Science and Research Branch, Islamic Azad University, Tehran, Iran
3 - 3) Associate Professor, Department of Environmental Health Engineering, Medical Sciences Branch, Islamic Azad University, Tehran, Iran.
4 - 2) Professor, Department of Environmental Engineering, Science and Research Branch, Islamic Azad University, Tehran, Iran
5 - 2) Professor, Department of Environmental Engineering, Science and Research Branch, Islamic Azad University, Tehran, Iran
Keywords: Formaldehyde, Kinetick model, Sono-electrochemistry, Taguchi, Ultrasound.,
Abstract :
According to the US Environmental Protection Agency, formaldehyde is classified as a Group 1 carcinogen. A threshold concentration of 1.61 mg/L of formaldehyde has been proposed to protect aquatic ecosystems. As a result, wastewater containing formaldehyde should be treated before discharge to the environment to protect aquatic ecosystems and human health. The aim of this applied research is to investigate the efficiency of formaldehyde removal from urban drinking water by the advanced sono-electrochemical oxidation process. This research was conducted on a laboratory scale and in a single-pole sono-electrochemical batch reactor. Certain amounts of formaldehyde were added to a sample of urban drinking water in Tehran. The removal efficiency was investigated using zinc-copper electrodes (due to the establishment of the best potential) in different conditions of pH (11-3), time (0-32 minutes), formaldehyde concentration (110-330 mg/L), current density (4-8 mW/cm2) and electric power (50-100 W). The measurement of the residual formaldehyde concentration was carried out by spectrophotometry at a wavelength of 400 nm using the colorimetric method with chromotropic acid 6252. The results were analyzed with absorption kinetic models and one-way analysis of variance. All stages of the research were carried out in accordance with ethical standards. The best removal conditions of 110 mg/L formaldehyde (100% efficiency) were obtained at a contact time of 32 min, an optimum pH of 3, a current density of 12 mA/cm2 and an electrical power of 150 W. The process followed a first-order kinetic model (R2 = 0.9994) and one-way analysis of variance. Concentration was the most important variable based on the formaldehyde removal efficiency obtained by the Taguchi model. This study provides new insights into the study of sono-electrochemical treatment for formaldehyde removal via direct oxidation (electrolysis and sonolysis) and indirect oxidation.
Abbas RN, and Abbas AS (2022) The Taguchi approach in studying and optimizing the electro-fenton oxidation to reduce organic contaminants in refinery wastewater using novel electrodes. Engineering, Technology & Applied Science Research 12:8928-8935.
Al-Marri S, AlQuzweeni SS, Hashim KS, AlKhaddar R, Kot P, AlKizwini RS, Zubaidi SL, and Al-Khafaji ZS (2020) Ultrasonic-Electrocoagulation method for nitrate removal from water. In IOP Conference Series: Materials Science and Engineering, pp 012073, IOP Publishing.
Almasi H, Asgari G, Leili M, Sharifi Z, and Seid-Mohammadi A (2017) The study of phenol removal from aqueous solutions using oxidizing agents of peroxide hydrogen, persulfate and periodate activated by ultrasound. Journal of Rafsanjan University of Medical Sciences 15:835-848.
Association APH (1926) Standard methods for the examination of water and wastewater. American Public Health Association.
Bello MM, Raman AAA, and Asghar A (2019) A review on approaches for addressing the limitations of Fenton oxidation for recalcitrant wastewater treatment. Process Safety and Environmental Protection 126:119-140.
Choi Y, Lee D, Hong S, Khan S, Darya B, Lee J-Y, Chung J, and Cho S-H (2020) Investigation of the synergistic effect of sonolysis and photocatalysis of titanium dioxide for organic dye degradation. Catalysts 10:500.
Çokay E, Eker S, and Taşkın E (2024) Treatment of table olive processing wastewater with US/UV processes. Heliyon 10.
Farhoodi AM, Hassani AH, Kashi G, Javid AH, and Mansouri N (2024) Optimization of the electro-photocatalytic process for the removal of formaldehyde from water using the Taguchi model. Heliyon.
Hashemzadeh F, and Borghei SM (2021) Study on application of electrocoagulation process to remove heavy metals lead, cadmium and chromium from water.
Hosseinzadeh A, Najafpoor AA, Navaei AA, Zhou JL, Altaee A, Ramezanian N, Dehghan A, Bao T, and Yazdani M (2021) Improving formaldehyde removal from water and wastewater by Fenton, photo-fenton and ozonation/fenton processes through optimization and modeling. Water 13:2754.
Hu D, Liu S, Qi L, Liang J, and Zhang G (2024a) A critical review on ultrasound-assisted adsorption and desorption technology: mechanisms, influencing factors, applications, and prospects. Journal of Environmental Chemical Engineering:114307.
Hu D, Liu S, and Zhang G (2024b) Sonochemical treatment for removal of aqueous organic pollutants: principles, overview and prospects. Separation and Purification Technology:128264.
Huang T, Zhang G, Chong S, Liu Y, Zhang N, Fang S, and Zhu J (2017a) Effects and mechanism of diclofenac degradation in aqueous solution by US/Zn0. Ultrasonics Sonochemistry 37:676-685.
Huang Y, Zhou T, Wu X, and Mao J (2017b) Efficient sonoelectrochemical decomposition of sulfamethoxazole adopting common Pt/graphite electrodes: The mechanism and favorable pathways. Ultrasonics Sonochemistry 38:735-743.
Iervolino G, Zammit I, Vaiano V, and Rizzo L (2020) Limitations and prospects for wastewater treatment by UV and visible-light-active heterogeneous photocatalysis: a critical review. Heterogeneous Photocatalysis: Recent Advances:225-264.
Jawale RH, and Gogate PR (2018) Combined treatment approaches based on ultrasound for removal of triazophos from wastewater. Ultrasonics sonochemistry 40:89-96.
Jawale RH, Gogate PR, and Pandit AB (2014) Treatment of cyanide containing wastewater using cavitation based approach. Ultrasonics sonochemistry 21:1392-1399.
Kashi G (2017) Optimization of electrochemical process for phenanthrene removal from aqueous medium by Taguchi. Toxicological & Environmental Chemistry 99:772-782.
Kashi G, and Hydarian N (2015) Optimization electrophotocatalytic removal of sulfanilamide from aqueous water by taguchi model. Journal of Mathematics 2015:86-98.
Kashi G, and Khoshab F (2015) Proxy electrochemical process for Acid humic. Ciência e Natura 37:41-48.
Khodabakhshi A, Hatami V, Hemati S, and Sadeghi M (2020) Removal of Formaldehyde from Aqueous Solutions by Advanced Oxidation Processes: UV/S: 2: O: 8: 2-:/Fe: 2+: and UV/S: 2: O: 8: 2. International Journal of Environmental Health Engineering 9:20.
Korake SR, and Jadhao PD (2021) Investigation of Taguchi optimization, equilibrium isotherms, and kinetic modeling for cadmium adsorption onto deposited silt. Heliyon 7.
Li H, Sang Y, Chang S, Huang X, Zhang Y, Yang R, Jiang H, Liu H, and Wang ZL (2015) Enhanced ferroelectric-nanocrystal-based hybrid photocatalysis by ultrasonic-wave-generated piezophototronic effect. Nano letters 15:2372-2379.
Licht K, Halkijevic I, Posavcic H, and Kosar V (2023) Study of ultrasound, initial concentration and electrode material on the electrochemical removal of selenium and strontium. Chemical Engineering and Processing-Process Intensification 191:109457.
Majd MH, Rajaei A, Bashi DS, Mortazavi SA, and Bolourian S (2014) Optimization of ultrasonic-assisted extraction of phenolic compounds from bovine pennyroyal (Phlomidoschema parviflorum) leaves using response surface methodology. Industrial Crops and Products 57:195-202.
Mehralipour J, and Kermani M (2019) Optimization of the ultrasonic-electroproxone process via graphene-titanium electrodes in removal of 2, 4 D from synthetic wastewater by RSM.
Nowshad F, Islam MN, and Khan MS (2018) Concentration and formation behavior of naturally occurring formaldehyde in foods. Agriculture & Food Security 7:1-8.
Olya M, Pirkarami A, Soleimani M, and Yousefi Limaee N (2013) Decolorization of acid dye using sono-based processes: sonoelectrochemical, sonophotoelectrochemical and sonophotoelectrocatalysis. Progress in Color, Colorants and Coatings 7:105-120.
Panahi A, Kamani H, Sancholi F, and Havangi M (2017) Efficiency evalution ultrasonic/Fenton process in removal of antibiotic Penicillin G from aquatic solution by response surface methodology.
Rahmani AR, Shabanloo A, Mehralipour J, Fazlzadeh M, and Poureshgh Y (2015) Degradation of phenol in aqueous solutions using electro-fenton process. Research Journal of Environmental Sciences 9:332.
Raschitor A, Llanos J, Cañizares P, and Rodrigo MA (2020) Improved electrolysis of colloid-polluted wastes using ultrasounds and electrocoagulation. Separation and Purification Technology 231:115926.
Rayaroth MP, Aravind UK, and Aravindakumar CT (2015) Sonochemical degradation of Coomassie Brilliant Blue: Effect of frequency, power density, pH and various additives. Chemosphere 119:848-855.
Ren Y-Z, Franke M, Anschuetz F, Ondruschka B, Ignaszak A, and Braeutigam P (2014) Sonoelectrochemical degradation of triclosan in water. Ultrasonics Sonochemistry 21:2020-2025.
Salman RH (2019) Removal of manganese ions (Mn2+) from a simulated wastewater by electrocoagulation/electroflotation technologies with stainless steel mesh electrodes: process optimization based on Taguchi approach. Iraqi Journal of Chemical and Petroleum Engineering 20:39-48.
Shestakova M, Vinatoru M, Mason TJ, Iakovleva E, and Sillanpää M (2016) Sonoelectrochemical degradation of formic acid using Ti/Ta2O5-SnO2 electrodes. Journal of Molecular Liquids 223:388-394.
Sheydaei M, Fattahi M, Ghalamchi L, and Vatanpour V (2019) Systematic comparison of sono-synthesized Ce-, La-and Ho-doped ZnO nanoparticles and using the optimum catalyst in a visible light assisted continuous sono-photocatalytic membrane reactor. Ultrasonics sonochemistry 56:361-371.
Shojaei A, Moeinian K, and Rostami R (2024) Removal of formaldehyde from the air flow in an electrochemical process. Process Safety and Environmental Protection 190:1040-1051.
SOLTANI RDC, Khataee A, Mashayekhi M, and Safari M (2016) Photocatalysis of formaldehyde in the aqueous phase over ZnO/diatomite nanocomposite. Turkish Journal of Chemistry 40:402-411.
Soltani RDC, Rezaee A, Safari M, Khataee A, and Karimi B (2015) Photocatalytic degradation of formaldehyde in aqueous solution using ZnO nanoparticles immobilized on glass plates. Desalination and Water Treatment 53:1613-1620.
Tran N, Drogui P, Brar SK, and De Coninck A (2017) Synergistic effects of ultrasounds in the sonoelectrochemical oxidation of pharmaceutical carbamazepine pollutant. Ultrasonics sonochemistry 34:380-388.
Tran N, Drogui P, Zaviska F, and Brar SK (2013) Sonochemical degradation of the persistent pharmaceutical carbamazepine. Journal of environmental management 131:25-32.
ul Nisa T, Khokhar WA, Imran U, Khokhar SA, and Soomro N (2023) Electrochemical treatment of wastewater containing urea-formaldehyde and melamine-formaldehyde. Chemosphere 338:139587.
Villaroel E, Silva-Agredo J, Petrier C, Taborda G, and Torres-Palma RA (2014) Ultrasonic degradation of acetaminophen in water: effect of sonochemical parameters and water matrix. Ultrasonics sonochemistry 21:1763-1769.
Yousefi M, Akbari H, Adibzadeh A, Mohammadi AA, Baziar M, Farajzadeh MA, and Akbari H (2024) Adsorption of diazinon from aqueous solution using metal organic framework and functionalized graphene: Comparison of BBD, ANN models. Chemosphere 351:141222.
Yousefi M, Nabizadeh R, Alimohammadi M, Mohammadi AA, and Mahvi AH (2019) Removal of phosphate from aqueous solutions using granular ferric hydroxide process optimization by response surface methodology. Desalin Water Treat 158:290-300.
Zhang Y, Wang M, San X, Zhang L, Wang N, Wang G, Meng D, and Shen Y (2024) Highly selective gas sensors for formaldehyde detection based on ZnO@ ZIF‑8 core-shell heterostructures. Sensors and Actuators B: Chemical 398:134689.
اردکانی س, سهیل, جعفری, سیدمیلاد, and احتشامی (2016) ارزیابی کارایی فرآیند الکترولیز در حذف پیراسنجه های اکسیژن خواهی شیمیایی و کل ذرات معلق از پساب کارخانجات کشمش پاک کنی. علوم و تکنولوژی محیط زیست 18:377-386.