Biosorption of Mn (II) and Removal of Reactive Black B by Combined Biosorption-U/H2O2 Processesin Unit Reactor from Wastewater

Subject Areas : BIotecnology

rana khalilnezhad ¹ (Department of Applied Chemistry, Payamenoor University, Tehran, Iran *(Corresponding author))
reza marandi ² (Department of Environmental Engineering, Faculty of Engineering, North Tehran Branch, Islamic Azad university, Tehran, Iran)
Morteza Khosravi ³ (Department of Applied Chemistry, Faculty of Chemistry, North Tehran Branch, Islamic Azad university, Tehran, Iran)

Received: 2017-02-10 Accepted : 2017-08-16 Published : 2019-11-22

Keywords: Sodium alginate, Reactor, Process, combined, Biosorption,

Abstract :

Background and Objective: Heavy metals and dyes are released into the environment by industrial activities and technological development more than natural. Because of their toxicity, they have anomalous effects on the environment and on the health of organisms, especially humans. Method: In this research, two methods of advanced oxidation and biological adsorption were combined in a single reactor and the pollutants were introduced into the reactor and the percentages of their removal were investigated. . The UV / H2O2 process was used to remove the RBB dye and to remove the manganese ion from a biological adsorbent fixed in sodium alginate. After performing these two processes in the batch system and considering the optimum conditions in the unit reactor, these two processes were combined and the granules were poured into a polyethylene filter and placed inside the reactor embedded in the center of the UV lamp. Findings: According to the results of TOC and COD, it was found that in the case of only UV / H2O2 process, the percent removal of TOC and COD were 35% and 79.5%, respectively, but in the combined condition, the percentage of TOC reduction was 56% and COD It reaches 90.22%. Discussion and Conclusion: The results have shown that the removal efficiency both in terms of decolorization and mineralization is negligible when UV, H2O2 or biosorbent are used alone. Among combining AOP with- biological process schemes tested, we found that the UV/H2O2/biosorbent process was the most effective in reducing the COD, color and TOC of decolorization

References:

1. Oller, I., Malato, S., Sanchez-Perez, J.A. 2011. Combination of Advanced Oxidation Processes and biological treatments forwastewater decontamination—A review. Science of the Total Environment. Vol.409, pp.4141-4166.


2. Mesdaghinia, A.R., Farrokhi, M., Nasseri, S. 2003. Biodegradability of 2, 4, 6 trichlorophenol (TCP) by fenton, s oxidation process. Hakim Research Journal, Vol. 2(7), pp. 23-40.


3. Dixit, A., Tirpude, A. J., Mungray, A.K. 2011. Degradation of 2, 4 DCP by sequential biological–advanced oxidation process usingUASB and UV/TiO2/H2O2, Desalination. Vol. 272, pp. 265-269.


4. Lafi, W., Shannak, B., Al-Shannag, M., Al-Anber, Z., Al-Hasan, M. 2009, Treatment of olive mill wastewater by combined advanced oxidation and biodegradation.  Separation and purification Technology, Vol. 70, pp. 141-146.


5. Mandal, T., Maity, S., Dasgupta, D., Datta, S. 2010.  Advanced oxidation process and biotreatment: Their roles in combined industrial wastewater treatment. Desalination, Vol. 250, pp. 87-94.


6. Moussavi, G., Yazdanbakhsh, A., Heidarizad, M. 2009, the removal of formaldehyde from concentrated synthetic wastewater using O3/MgO/H2O2 process integrated with the biological treatment. Hazardous Materials, Vol. 171, pp. 907-913.


7. Barreto-Rodrigues, M., Souza, V. B. J., Silva, E. S., Silva, F. T., Paiva, T. C. B. 2007. Combined photocatalytic and fungal processes for the treatment of nitrocellulose industry wastewater.  Hazardous Materials, Vol. 161, pp. 1560-1573.


8. Moradi Pasand, L., Ayati B. 1392. Study of reactive blue 171 dye degradation in hybrid system of UV/H₂O₂& SBAR. Iran. J. Health & Environ., 2013, Vol.6, No. 3, pp.393-406. (Persian)


9. Yao-Hui Huang∗, Shu-Ting Tsai, Yi-Fong Huang, Chuh-Yung Chen. 2007, Degradation of c.ommercial azo dye reactive Black B in photo/ferrioxalate system, Journal of Hazardous Materials, 140, 382–388.


10. Sedighi M, khosravi V, Ramedani A, 2012. Estimating the Impact of Important Parameters on Biosorption of Cu and Mn Ions by Bacillus Thuringiensis. NCMBJ. 2 (8) ,45-51. (Persian)


11. Fadel, M., Hassanein, N.M., Elshafei, M.M., Mostafa, A.H, Ahmed , M.A.,  Khater, H.M, 2015,  Biosorption of manganese from groundwater by biomass of Saccharomyces cerevisiae Housing and Building National Research Center, 1-8


12. Hassimi Abu Hasan , H., Sheikh Abdullah, S.R., Tan Kofli,, N., Yeoh, S.J, 2016,  Interaction of environmental factors on simultaneous biosorption of lead and manganese ions by locally isolated Bacillus cereus, Journal of Industrial and Engineering Chemistry 37 , 295–305


13. K. Vijayaraghavan, Heng Yun Ni Winnie, R. Balasubramanian,  Biosorption characteristics of crab shell particles for the removal of manganese(II) and zinc(II) from aqueous solutions, Desalination 266 (2011) 195–200


14. Kapoor, A., Viraraghavan, T., Cullimore, D. R. 1999.  Removal of heavy metals the fungus Aspergillus niger.  Bioresource Technology, Vol. 70, pp. 95-104.


15. Marandi. R. 2011. Biosorption of Hexavalent Chromium from Aqueous Solution by Dead Fungal Biomass of Phanerochaete crysosporium: Batch and Fixed Bed Studies.  Chemical Engineering & Technology, Vol. 2, pp.8-22.


16. Preetha, B., Viruthagiri, T. 2007, Batch and continuous biosorption of chromium (VI) by Rhizopus Arrhizus, Separation and Purification Technology. Vol. 57, pp. 126–133.


17. Ghodbane, H., Hamdaoui, O. 2010. Decolorization of antraquinonic dye, C.I. Acid Blue 25, in aqueous solution by direct UV irradiation, UV/H₂O₂ and UV/Fe(II) processes, Chemical Engineering Journal, Vol. 160 , pp. 226–231.


18. Afzal, A., Oppenlander, T. R., Bolton, J., Mohamed Gamal El-Din, M. 2010. Anatoxin-a degradation by Advanced Oxidation Processes: Vacuum-UV at 172 nm, photolysis using medium ressure UV and UV/H2O2. WATER RESERCH, Vol.44 , pp. 278 – 286


19. 19.Gul, S. S., Ozcan-Yildirım, O. 2009, Degradation of Reactive Red 194 and Reactive Yellow 145 azo dyes by O₃ and H₂O₂/UV-C processes, Journal Chemical Engineering, Vol. 155, pp. 684–690.


20. Schrank, S. G., Santos, J. N .R., Santos Souza, D., Santos Souza, E. E. 2007. Decolourisation effects of Vat Green 01 textile dye and textile wastewater using H2O2/UV process, Journal of Photochemistry and Photobiology A: Chemistry. Vol. 186, pp. 125–129


21. Huang, Y. H., Tsai, S. T., Huang, Y.F., Chen, C. Y. 2007. Degradation of commercial azo dye reactive Black B in photo/ferrioxalate system, Journal of Hazardous Materials, Vol.140 , pp. 382–388


22. Shu, H. Y., Chang, M .C. 2006. Development of a rate expression for predicting decolorization of C.I. AcidBlack 1 in a UV/H2O2 process, Dyes and Pigments, Vol.70, pp. 31-37.


23. Yang, Y., Wang, G., Wang, B., Li, Z., Jia, X., Zhou, Q., Zhao, Y., 2011, Biosorption of Acid Black 172 and Congo Red from aqueous solution by nonviable Penicillium YW 01: Kinetic study, equilibrium isotherm and artificial neural network modeling, Bioresource Technology, Vol.102, PP. 828–834. 


24. Pathak, C.S., Agarwala, V., Mandal, M.K., 2012, Mechano-chemical synthesis and optical properties of ZnS nanoparticles, Physica B: Condensed Matter., Vol. 407, PP. 3309-3312


25. Yang, C., Wang, J., Lei, M., Xie, G., Zeng, G., Luo, S.,2010, Biosorption of zinc(II) from aqueous solution by dried activated sludge, Journal of Environmental Sciences, Vol. 22, PP. 675–680.


26. Vijayaraghavan, K., Teo, T. T. 2009. Application of Sargassum biomass to remove heavy metal ions from synthetic multi-metal solution and urban strom water runoff Balasubramanian, R;  Joshi, U.M;  Hazardous Materials, Vol. 164, pp. 1019-1023.


27. Joo, J.H., Hassan, S.H.A., Oh, S.E., 2010, Comparative study of biosorption of Zn+2 by Pseudomonas aeruginosa and Bacillus cereus, International Biodeterioration & Biodegradation, Vol. 64, PP. 734-741


28. Areco, M.M., Afonso, M.D.S., 2010, Copper, zinc, cadmium and lead biosorption by Gymnogongrus torulosus. Thermodynamics and kinetics studies, Colloids and Surfaces B: Biointerfaces., Vol. 81, PP. 620-628


29. Mungasavalli, D. P, Viraraghavan, T,., Jin, Y. C. 2007. Biosorption of chromium from aqueous solutions by pretreated Aspergillus niger: Batch and column studies, Colloids and Surfaces, A: Physicochem. Eng. Aspects, Vol.301, pp. 214–223.


30. Han, R., Wang, Y., Yu, W., Zou, W., Shi, J., Liu, H. 2007. Biosorption of methylene blue from aqueous solution by rice husk in a fixed-bed column, Journal of Hazardous Materials, Vol. 141, pp. 713–718.


31. Areco, M.M., Afonso, M.D.S. 2010, Copper, zinc, cadmium and lead biosorption by Gymnogongrus torulosus. Thermodynamics and kinetics studies, Colloids and Surfaces B: Biointerfaces, Vol.81, pp. 620-628.


32. Zhang, H., Wu, X., Li, X. 2012. Oxidation and coagulation removal of COD from landfill leachate by Fered–Fenton process, Chemical Engineering Journal, Vol. 210, pp.  188-194.


33. Xueming Tang, X., Linda, K., Weavers, L.K. 2008. Using photoactivated periodate to decompose TOC from hydrolysates of chemical warfare agents, Journal of Photochemistry and Photobiology A: Chemistry, Vol.194, pp. 212-219.


34. Aleboyeh, A., Olya, M.E., Aleboyeh, H. 2008. Electrical energy determination for an azo dye decolorization and mineralization by UV/H2O2 advanced oxidation process, Chemical Engineering Journal, Vol.137, pp. 518–524.