Synthesis and Characterization of Activated Carbon Photocatalyst Modified with ZnO/SnO2 Nanoparticles and Its Application in the Municipal Wastewater Treatment with Advanced Oxidation Process

Subject Areas : journal of New Materials

Amirali Jahanbakhshi nejad ¹ , Hakimeh Sharififard ² , Mohammad Bonyadi ³ , Raziye Hayati ⁴

1 - M. Sc Student-Chemical Engineering Department- Yasouj University, Yasouj, Iran
2 - Assistant Professor-Chemical Engineering Department- Yasouj University- Yasouj, Iran
3 - Associate Professor-Chemical Engineering Department-Yasouj University- Yasouj, Iran
4 - Assistant Professor-Materials Engineering Department-Yasouj University, Yasouj, Iran

Received: 2023-12-30 Accepted : 2024-02-26 Published : 2023-07-23

Keywords: Activated Carbon, Municipal wastewater, Advanced oxidation process, Agriculture wastes,

Abstract :

Abstract
Due to the increase in population and industrial activities, the demand for clean water has increased. On the other hand, the amount of fresh water has decreased; As a result, wastewater treatment, including municipal and industrial wastewater, has become very necessary. One of the wastewater treatment methods is the Advanced Oxidation Process (AOP). This research used the advanced oxidation process using the photo-catalyst based on modified activated carbon to treat municipal wastewater in Yasouj City. Activated carbon was prepared from the walnut shell using the chemical activation method and then modified by a composite of ZnO and SnO₂ nanoparticles and used as a photo-catalyst in the designed reactor for wastewater treatment. The results of FTIR, XRD, and EDX analyses confirmed the presence of ZnO/SnO₂ nanoparticles on the modified activated carbon surface. Due to the coating of these nanoparticles on the surface of the activated carbon and inside its pores, the specific surface area of the modified activated carbon is greatly reduced compared to the activated carbon. The results of the DRS analysis show the low band gap of the synthesized photocatalyst and its applicability in the presence of visible light. To optimize the effect of the parameters, the central composite design method was used to design the experiment. The results showed that the maximum amount of COD reduction of 97.41% has been achieved at a pH of 3, the amount of photocatalyst of 1.25 g/L, and the duration of light irradiation of 45 minutes.

References:

[1] Isha Arora, Harshita Chawla, Amrish Chandra, Suresh Sagadevan, Seema Garg; Advances in the strategies for enhancing the photocatalytic activity of TiO2: Conversion from UV-light active to visible-light active photocatalyst, Inorganic Chemistry Communications, 143, 109700 (2022).

[2] Marwah A. Al‑Nuaim, Asawer A. Alwasiti, Zainab Y. Shnain, The photocatalytic process in the treatment of polluted water, Chemical Papers (2023) 77:677–701.

[3] T. Biyang, C. Hang, D. Jiahui, X. Shan, M. Xiaoyn, X. Yinqi, X. Zongfan, T. Haisheng; Preparation of N-I co-doped TiO2 supported on activated carbon photocatalyst for efficient photocatalytic reduction of Cr(VI) ions, Colloids and Surfaces A: Physicochemical and Engineering Aspects 622 (2021) 126660.

[4] M. Alsaiari, Biomass-derived active carbon (AC) modified TiO2 photocatalyst for efficient photocatalytic reduction of chromium (VI) under visible light, Arabian Journal of Chemistry (2021) 14, 103258.

[5] K.S. Bhavsar, P.K. Labhane, R.B. Dhake, G.H. Sonawane; Solvothermal Synthesis of Activated Carbon Loaded CdS Nanoflowers: Boosted photodegradation of dye by adsorption and photocatalysis synergy, Chemical Physics Letters 744 (2020) 137202.

[6] M. Murugesan, M. Loganathan, P. Senthil Kumar, D.V. N. Vo, Cobalt and nickel oxides supported activated carbon as an effective photocatalysts for the degradation Methylene Blue dye from aquatic environment, Sustainable Chemistry and Pharmacy 21 (2021) 100406.

[7] L. O. Pereira, I. M. Sales, L. P. Zampiere, S. S. Vieira, I. R. Guimaraes, F. Magalhaes, Preparation of magnetic photocatalysts from TiO2, activated carbon and iron nitrate for environmental remediation, Journal of Photochemistry and Photobiology A: Chemistry 382 (2019) 111907.

[8] P. Amornpitoksuk, S. Suwanboon, C. Randorn, Photocatalytic activities of silver compound modified activated carbon@ ZnO: Novel ternary composite visible light-driven photocatalysts, Materials Science in Semiconductor Processing 84 (2018) 50–57.‏

[9] K. Pirkanniemi, M. Sillanpqaa, Heterogeneous water phase catalysis as an environmental application: a review Chemosphere, 48, 2002, 1047.‏

[10] Y. Alivov, C. Liu, A. Teke, M. Reshchikov, S. Dogan, V. Avrutin, J. Cho, H. Morko, A comprehensive review of ZnO materials and devices, Journal of Applied Physics., 98, 2005, 41301.‏

[11].‏ Xin, Z.; He, Q.; Wang, S.; Han, X.; Fu, Z.; Xu, X.; Zhao, X. Recent Progress in ZnO-Based Nanostructures for Photocatalytic Antimicrobial in Water Treatment: A Review. Appl. Sci. 2022, 12, 7910.

[12] S. Anandan, A. Vinu, T. Mori, N. Gokulakrishnan, P. Srinivasu, V. Murugesan, Photocatalytic Degradation of 2,4,6-Trichlorophenol Using Lanthanum Doped ZnO in Aqueous Suspension, Journal of Catalysis Communications, 8, 2007, 1377.

[13] A. Mahmood, M. T. Noman, M. Pechociakova, N.Amor, B. Tomkova, J. Militky, Energy efficient industrial and textile waste for the fabrication of cementitious composites: a review. The Journal of The Textile Institute, 1, 2023, 1-17.

[14] Drake C., (2003), PhD.thesis “Undestanding the low temperature electrical properties of nanocrustalline SnO2 for gas sensor application”, Material Depart. University of Florida.

[15] do Nascimento, J.L.A.; Chantelle, L.; dos Santos, I.M.G.; Menezes de Oliveira, A.L.; Alves, M.C.F. The Influence of Synthesis Methods and Experimental Conditions on the Photocatalytic Properties of SnO2: A Review. Catalysts 2022, 12, 428.

[16] Chiang, Y.J., Lin, C.C., Photocatalytic decolorization of methylene blue in aqueous solutions using coupled ZnO/SnO2 photocatalysts, Powder Technology, 246, 2013, 137-143.

[17] Kadem, A. J., Tan, Z. M., Mohana Suntharam, N., Pung, S., Ramakrishnan, S. (2023). Synthesis of CuO, ZnO and SnO2 Coupled TiO2 Photocatalyst Particles for Enhanced Photodegradation of Rhodamine B Dye. Bulletin of Chemical Reaction Engineering & Catalysis, 18 (3), 506-520.

[18] L Niazi, A Lashanizadegan, H Sharififard, Chestnut oak shells activated carbon: Preparation, characterization and application for Cr (VI) removal from dilute aqueous solutions, J. Cleaner Production, 185, 554-561, 2018.

[19] Hashemi-Shahraki Z, Sharififard H, Lashanizadegan A. Grape stalks biomass as raw  material for activated carbon production: synthesis, characterization and adsorption ability. Materials Research Express 5(5), 2018, 055603.

[20] M.M. Sabzehmeidani, H. Karimi, M. Ghaedi; Visible light induced photo-degradation of methylene blue by n–p heterojunction CeO2/CuS composite based on ribbon-like CeO2 nanofibers via electrospinning, Polyhedron 170 (2019) 160–171.

[21] Scipioni R, Gazzoli D, Teocoli F, Palumbo O, Paolone A, Ibris N, Brutti S, Navarra MA. Preparation and characterization of nanocomposite polymer membranes containing functionalized SnO2 additives. Membranes 2014; 4: 123–42.

[22] Fageria P, Gangopadhyay S, Pande S. Synthesis of ZnO/Au and ZnO/Ag nanoparticles and their photocatalytic application using UV and visible-light. RSC Adv 2014;4: 24962–72.

[23] Haibo O, Feng HJ, Cuiyan Li, C.Liyun FJie. Synthesis of carbon doped ZnO with porous structure and its solar-light photocatalytic properties. Mater Lett 2013;111: 217–20.

[24] Ismail Adel A, Harraz Farid A, Faisal M, El-Toni Ahmed Mohamed, Al-Hajry A, Al-Assiri MS. A facile synthesis of mesoporous Pd-ZnO nanocomposites as efficient chemical sensor. Superlattices Microstruct 2016;95: 128–39.

[25] Sahay PP, Mishra RK, Pandey SN, Jha S, Shamsuddin M. Structural, dielectric and photoluminescence properties of co-precipitated Zn-doped SnO2 nanoparticles. Curr Appl Phys 2013;13: 479–86.

[26] Hamed Tahmouresinejad, Parviz Darvishi, Asghar Lashanizadegan, Hakimeh Sharififard, Treatment of Olefin plant spent caustic by combination of Fenton‑like and foam fractionation methods in a bench scale, Environmental Science and Pollution Research (2022) 29:52438–52456.

[27] N. Jayan, L. Deepak-Bhatlu and S. Thalikassery Akbar, Central Composite Design for Adsorption of Pb(II) and Zn(II) Metals on PKM-2 Moringa oleifera Leaves, ACS Omega 6, 25277 (2021).

[28] Z.M. Shakor, A.A. Abdulrazak and A.A. Shuhaib, Optimization of process variables for hydrogenation of cinnamaldehyde to cinnamyl alcohol over a Pt/SiO2 catalyst using response surface methodology, Chem. Eng. Commun. 209, 827-843 (2022).

[29] A.D. Ogunsola, M.O. Durowoju, A.O. Alade, S.O. Jekayinfa and O. Ogunkunle, Modeling and optimization of two-step shea butter oil biodiesel synthesis using snail shells as heterogeneous base catalysts, Energy Adv. 1, 113 (2022).

 [30] Seyyedeh Cobra Azimi, Farhad Shirini, Alireza Pendashteh; Preparation and application of α-Fe2O3@TiO2@SO3H for photocatalytic degradation and COD reduction of woodchips industry wastewater. Environmental Science and Pollution Research (2021) 28:56449–56472.

[31] M.M. Sabzehmeidani, H. Karimi, M. Ghaedi, Enhanced visible light-active CeO2/CuO/Ag2CrO4 ternary heterostructures based on CeO2/CuO nanofiber heterojunctions for the simultaneous degradation of a binary mixture of dyes, New J. Chem., 2020,44, 5033-5048.

[32] محمدحسین برزگر، سنتز یک نمونه نانو فوتوکاتالیست به منظور تخریب برخی آلایندها از یک محیط آبی به کمک انرژی خورشیدی: بهینهسازی با طراحی آزمایش، پایا نامه کارشناسی ارشد، دانشگاه یاسوج، 1396.

[33] طاهره جعفری زاده، پیام حیاتی، حسن زارع نیریزی، زهره مهرآبادی، محمدحسین فرجام، بهینه سازی تخریب فوتوکاتالیستی آالینده دارویی سفالکسین از محلولهای آبی توسط نانو ساختارهای سنتزشده MOC-Zn با استفاده از روش سطح پاسخ، فصل­نامه علمی-پژوهشی مواد نوین، بهار 1400، شماره 43، 93-108.