Textural Properties Changes During Facile Drying of Sour Cherry Using Ultrasound Waves: Investigation of Sonication Parameters Using Response Surface Methodology

Subject Areas : food microbiology

P.  Adavi ¹ (MSc. Student of the Department of Food Science and Technology, Science and Research Branch, Islamic Azad University, Tehran, Iran.)
S.  Askari ² (Assistant Professor of the Department of Chemical Engineering, Science and Research Branch, Islamic Azad University, Tehran, Iran.)
Gh.  Asadi ³ (Assistant Professor of the Department of Food Science and Technology, Science and Research Branch, Islamic Azad University, Tehran, Iran.)

Received: 2021-11-25 Accepted : 2021-11-25 Published : 2022-01-01

Keywords: Sour Cherry, Ultrasound-Assisted Drying, Sonication Parameters, Textural Properties,

Abstract :

There are a number of fruit drying methods and hot air flow drying has been considered the most common one. However, it is not an economical way due to the huge amount of energy consumption. Using ultrasound waves as a pre-treatment in drying may rise drying efficiency as well as alleviating the cost level. In this research, drying of sour cherry has been accomplished, applying ultrasound waves as a pre-treatment. In this case, the effects of ultrasound parameters i.e., sonication temperature, power intensity, and sonication time are discussed. The preliminary results illustrate the role of ultrasound waves as a pre-treatment, in which the drying time is already reduced from 7 hours to 3 hours; on the other hand, the maximum water loss has been achieved with sonication temperature of 30⁰C, power intensity of 147 w/cm2 and sonication time of 60 min. Moreover, the amount of moisture loss is surged through increasing the ultrasound exposing time, as compared to a conventional sample. It is worth mentioning that among these mentioned parameters, the temperature plays the most significant role on the water loss. Consequently, using ultrasound waves is a promising way for reducing the temperature, time and energy in hot air flow drying process.

References:

Ahari Hashemi, F. & Fatvarechian, S. (2006). Investigating and Investigating the Determination of Porosity Using Different Types of Densities in Graphite Structure. Journal of Science and Engineering, 38, 48-42.
Askari, S. & Halladj, R. (2012). Ultrasonic pretreatment for hydrothermal synthesis of SAPO-34 nanocrystals. Ultrasonic Sonochemsitry, 19, 554–559.
Adu, B. & Otten, L. (1996). Effect of increasing hygroscopicity on the microwave heating of solid foods. Journal of Food Engineering, 27, 35-44
Chaovanalikit, A. & Wrolstad, R. E. (2004). Total anthocyanin and total phenolic of fresh and processed cherries and their antioxidant properties. Journal of Food Science, 69, 67-72.
Chelladurai, S. J. S., Murugan, K., Ray, A. P., Upadhyaya, M., Narasimharaj, V. & Gnanasekaran, S. (2021). Optimization of process parameters using response surface methodology: A review. Materials Today: Proceedings, 37, 1301-1304
Doymaz, I. (2004). Effect of dipping treatment on air drying of plums. Journal of Food Engineering, 64, 465-470.
Dueik, V., Marzullo, C. & Bouchon, P. (2013). Effect of vacuum inclusion on the quality and the sensory attributes of carrot snacks. LWT-Food Science and Technology, 50, 361–365.
Dissa, A., Desmorieux, O., Bathiebo, H. & Koulidiati, J. (2008). Convective drying characteristics of Amelie mango (Mangifera Indica L. cv. ‘Amelie’) with correction for shrinkage. Journal of Food Engineering, 88, 429-437.
Dadali, G., Apar, D. K. & Ozbek, B. (2007a). Microwave drying kinetics of okra. Drying Technology, 25, 917-924.
Ertekin, C. & Heybeli, N. (2006). Thin Layer Infrared Drying of Mint Leaves. Journal of Food Processing and. Preservation, 38, 1480-1490.
Ertekin, C. & Yaldiz, O. (2004). Drying of eggplant and selection of a suitable thin layer drying model. Journal of Food Engineering, 63, 349–359.
Eyiler, E. & Oztan, A. (2010). Production of frankfurters with tomato powder as a natural additive. Food Science and Technology, 44, 307- 311.
Ersus, S. & Yurdagel, U. (2007). Micro Microencapsulation of anthocyanin pigments of black carrot (Daucuscarota L.) by spray drier. Journal of Food Engineering, 80, 805–812.
Ferretti, G., Bacchetti, T., Belleggia, A. & Neri, D. (2010). Cherry antioxidants: from farm to table. Molecules, 15,6993-7005.
Fernandes, F. A. N., Rodrigues, S., Gaspar, O. C. & Oliveira, P. (2006). Optimization of osmotic dehydration of bananas followed by air drying. Journal of Food Engineering, 77, 188–193.
Feng, D. & Zhang, S. (2001). Multimedia Information Retrieval and Management, Technological Fundamentals and Applications, Springer-Verlag Berlin Heidelberg.
Gallego-Juarez, J. A., Fuente-Blanco, S. D. L., Serbia, E. R. F. D., Acosta-Aparicio, V. M. & Blanco-Blanco, A. (2007). Food drying process by power ultrasound. Ultrasonic, 44, 523-527.
Hammami, C., Rene, F. & Marin, M. (1999). Process quality optimization of the vacuum freeze- drying of apple slices by the response surface method. International Journal of Food Science and Technology, 34, 145-160.
Ioannou, I., (2011). Frozen Mirabelle plum drying: Kinetics, modelling, and impact on biochemical properties. Food and Bio Products Processing, 89, 438-448.
Isadora, M., Oliveirafabiano, A., Fernandes, N., Solei, R., Sousa, H. M., Geraldo, A. & imundo, W. F. (2006). Modeling and optimization of osmotic dehydration of banana Followed by air drying. Journal of Food Process Engineering, 29, 400-413.
Jazini, M. H. & Hatamipour, M. S. (2010). A new physical pretreatment of plum for drying. Food and Bio Products Processing, 88, 133-137.
Kouassi, K. & Roos, H. Y. (2001). Glass transition and water effects on sucrose inversion innoncrystalline carbohydrate food systems. Food research international, 34: 895-901.
Lerici, C. R., Mastrocola, D. & Nicoli, M. C. (1988). Use of direct osmosis as fruit and vegetables dehydration, Act- Alimentaria Polonica, 14, 35 – 40.
Lewicki, P. (2004). Water as the determinant of food engineering properties, A review. Journal of Food Engineering, 61, 483-495.
Mouskoki, A. (2007). Investigating the combined effect of ultrasound and alkaline waves on reducing the drying time of grapes and raisin production. Iranian Journal of Nutrition and Food Technology, 2,1-10.
Menges, H. O. & Ertekin, C. (2006). Thin layer drying model for treated and untreated Stanley plums. Energy Conversion and Management, 47, 2337-2348.
Raouzeos, G. S. & Saravacos, G. D. (1986). Solar drying of raisins. Drying Technology, 4,633–649.
Rodríguez, Ó., Santacatalina, J. V., Simal, S., Garcia-Perez, J. V., Femenia, A. & Rosselló, C., (2014). Influence of Power Ultrasound Application on Drying Kinetics of Apple and Its Antioxidant and Microstructural Properties. Journal of Food Engineering, 129, 21–29.
Rouquerol, F., Rouquerol, J. & Sink, K. (1999). Adsorption by Powder and Porous Solids, Academic press, London, 1-25.
Roohollahi, H., Halladj, R., Askari, S. & Yaripour, F. (2018). SAPO-34/AlMCM-41, as a novel hierarchical nanocomposite: preparation, characterization and investigation of synthesis factors using response surface methodology. Journal of Solid State Chemistry, 262, 273–281.
Shimada, K., Fujiyama, K., Yahara, K. & Nakamura, T. (1992). Antioxidative properties of xanthin on autoxidation of soybean oil in cyclodextrin emulsion. Journal of Agricultural and Food Chemistry, 40, 945-948.
Serdaroglu, M. & Ozsumer, M. S. (2003). Effects of Soy protein, Why Powder and Wheat Gluten on Quality Characteristics of Cooked Beef Sausages Formulated with 5, 10 and 20% Fat. Electronic Journal of Polish Agricultural Universities, 6, 1-30.
Talebi, J., Halladj, R. & Askari, S. (2010). Sonochemical synthesis of silver nanoparticles in Y-zeolite substrate. Journal of Material Science, 45, 3318–3324.
Thakur, B. R., Singh, R. K. & Nelson, P. )1996(. Quality attributes of processed tomato products: A review. Food Research International, 12, 375-401.
Vahideh, R. R. N., Narendra, J. & Gabriel, F. (2008). Effect of osmotic pre-dehydration on drying characteristics of banana Fruits. Journal of Food Technology, 28, 269-273.
Yan, Z., Sousa-Gallagher, M. J. & Oliveira, F. A. R. (2008). Shrinkage and porosity of banana, pineapple and mango slices during air-drying. Journal of Food Engineering, 84, 430-440.