Optimization of Energy Consumption in Milk Production Units through Integration of Data Envelopment Analysis Approach and Sensitivity Analysis

Subject Areas : Camel

ح. سلطانعلی ¹ , ب. عمادی ² , ع. روحانی ³ , م. خجسته‪پور ⁴ , ا. نیکخواه ⁵

1 - Department of Biosystems Engineering, Ferdowsi University of Mashhad, Mashhad, Iran
2 - Department of Biosystems Engineering, Ferdowsi University of Mashhad, Mashhad, Iran
3 - Department of Biosystems Engineering, Ferdowsi University of Mashhad, Mashhad, Iran
4 - Department of Biosystems Engineering, Ferdowsi University of Mashhad, Mashhad, Iran
5 - Young Researchers and Elite Club, Rasht Branch, Islamic Azad University, Rasht, Iran

Received: 2015-02-05 Accepted : 2015-05-15 Published : 2016-03-01

Keywords: Sensitivity analysis, Efficiency, milk production, energy modeling,

Abstract :

The aims of this study were to evaluate the energy consumption and its modeling in industrial milk production units using data envelopment analysis (DEA) approach and sensitivity analysis. Data were collected from 44 industrial milk production units in Guilan province of Iran with face to face questionnaire method during 2012-2013. Inputs included animal feed, fossil fuels, electricity, machinery and human labor and output was milk yield. The results highlighted that the highest share of energy consumption belonged to the animal feed (82%) followed by fossil fuels (13%). The results of DEA application revealed that the technical efficiency (TE) was 44.6%, pure technical efficiency (PTE) was 74.48% and scale efficiency (SE) was 0.53 for the investigated units. The results of variable returns to scale (VRS) illustrated that out of 44 producers considered for the analysis, 15 units were purely technically efficient in energy consumption from the different sources. The greatest potential inputs for saving energy were related to animal feed and diesel fuel, respectively. About 3852.39 MJ (47.74% of total energy input) could be saved without reducing the milk yield through following recommendations resulted from this study. Moreover, sensitivity analysis results showed that with one MJ extra use of human labor, fossil fuels and animal feed energy, it would lead to an additional increase in yield by 3.14, 1.36 and 0.95 kg, respectively. Also, one MJ extra energy use for either electricity or machinery result in a decrease in milk yield by 1.03 and 7.16 kg, respectively.

References:

Bakhoda H., Almassi M., Moharamnejad N., Moghaddasi R. and Azkia M. (2012). Energy production trend in Iran and its effect on sustainable development. Renew. Sust. Energ. Rev. 16, 1335-1339.

Banker R.D., Charnesn A. and Cooper W.W. (1984). Some models for estimating technical and scale inefficiencies in data envelopment analysis. Manag. Sci. 30(3), 1078-1092.

Brinker J. and Laurent A. (2011). Energy utilization index of wisconsin dairy farms. Am. Dairy Sci. Assoc. 3, 29-47.

Carter A. (2000). Investigating technical and scale efficiency of dairy farms in south-western Victoria: a nonparametric approach. Canadian J. Agric. Econ. 41, 169-194.

Charnes A., Copper W.W. and Rhodes E. (1984). Measuring the efficiency of decision marking units. Europian J. Operational. Res. 2(1), 429-444.

Cornejo C. and Wilkie A.C. (2010). Greenhouse gas emissions and biogas potential from livestock in Ecuador. Energ. Sust. Deve. 14(4), 256-266.

Divya P.I., Prabu M., Pandian A.S.S., Senthilkumar G. and Varathan B.J. (2012). Energy use efficiency in dairy of Tamilnadu. Indian J. Energ. 1(5), 50-55.

FAO. (2012). Food and Agriculture Organization of the United Nations (FAO), Rome, Italy.

Fujiwara M., Rushen J. and De Passillé A.M. (2014). Dairy calves’ adaptation to group housing with automated feeders. Appl. Anim. Behav. Sci. 158, 1-7.

Gerber P., Velling T., Opio C. and Steinfeld H. (2011). Productivity gains and greenhouse gas emissions intensity in dairy systems. Livest. Sci. 139, 100-108.

Ghojabeige F., Omid M., Ahmadi H. and Delshad D. (2009). Evaluation and development of efficient usage of energy recourses in cucumber production in green houses in province of Tehran, by using data envelopment analysis. Pp. in 1-8 Proc. 6^th Nation. Conf. Mech. Mechaniz. Agric. Mach. University of Tehran, Tehran, Iran.

Hosseini S.E., Andwari A.M., Wahid M.A. and Bagheri G. (2013). A review on green energy potentials in Iran. Renew. Sust. Energ. 27, 533-545.

Hu J.L. and Kao C.H. (2007). Efficient energy-saving targets for APEC economies. Energ. Policy. 35, 373-82.

Khojastehpour M., Nikkhah A. and Hashemabadi D. (2015). A comparative study of energy use and greenhouse gas emissions of canola production. Int. J. Agric. Manag. Dev. 5(1), 51-58.

Kraatz S. (2012). Energy intensity in livestock operations-modeling of dairy farming systems in Germany. Agric. Sys. 110, 90-106.

Kuswardhani N., Soni P. and Shivakoti G.P. (2013). Comparative energy input-output and financial analyses of greenhouse and open field vegetables production in west Java. Indonesia Energ. 53, 83-92.

Liu Y., Langer V., Høgh-Jense H. and Egelyng H. ( 2010). Life cycle assessment of fossil energy use and greenhouse gas emissions in Chinese pear production. J. Clean. Prod. 18, 1423-1430.

Maysami M.J., Olbertz H. and Ellmer F. (2013). Energy efficiency in dairy cattle farming and related feed production in Iran. MS Thesis. Faculty of Agriculture and Horticulture, Humboldt-Univ., Berlin, Germany.

Mohammadi M., Ghobadian B., Najafi G. and Galogah R.J. (2013). Potential of biogas production in Iran . Renew. Sust. Energ. Rev. 28, 702-714.

Mohammadi A., Rafiee S., Jafari A., Dalgaard T., Knudsen M.T., Keyhani A., Mousavi-Avval S.H. and Hermansen J.E. (2013). Potential greenhouse gas emission reductions in soybean farming: a combined use of life cycle assessment and data envelopment analysis. J. Clean. Prod. 54, 89-100.

Mousavi-Avval S.H., Rafiee S., Jafari A. and Mohammadi A. (2011). Optimization of energy consumption for soybean production using data envelopment analysis (DEA) approach. Appl. Energ. 88, 3765-3772.

Najafi G., Ghobadian B. and Yusaf T.F. (2011). Algae as a sustainable energy source for biofuel production in Iran: A case study. Renew. Sust. Energ. Rev. 15(8), 3870-3876.

Nikkhah A., Khojastehpour M., Emadi B., Taheri-Rad A. and Khorramdel S. (2015). Environmental impacts of peanut production system using life cycle assessment methodology. J. Clean. Prod. 92, 84-90.

O’Mara F.P. (2011). Greenhouse gases in animal agriculture-finding a balance between food production and emissions. Anim. Feed Sci. Technol. 7(15), 166-167.

Pahlavan R., Omid M., Rafiee S. and Mousavi-Avval S.H. (2012). Optimization of energy consumption for rose production in Iran. Energ. Sust. Dev. 16, 236-241.

Pishgar-Komleh S.H., Omid M. and Heidari M.D. (2013). On the study of energy use and GHG (greenhouse gas) emissions in greenhouse cucumber production in Yazd province. Energy. 59, 63-71.

Rahimizadeh M., Rezadost S., Mehraban A. and Marjani A. (2008). Energy analysis of ecological farming systems and strategies to increase energy efficiency. Pp. 33- 39 in Proc. 6^th Nation. Conf. Energ, Tehran, Iran.

Rajaeifar M.A., Akram A., Ghobadian B., Rafiee S.H. and Heidari M.D. (2014). Energy-economic life cycleassessment (LCA) and greenhouse gas emissions analysis of olive oil production in Iran. Energy. 66, 139-149.

Royan M., Khojastehpour M., Emadi B. and Mobtaker H.G. (2012a). Investigation of energy inputs for peach production using sensitivity analysis in Iran. Energ. Con. Man. 64,441-446.

Sainz R.D. (2003). Livestock-environment initiative fossil fuels component: framework for calculation fossil fuel use in livestock systems. Available at: http://www.fao.org.

Shafiee S. and Topal E. (2009). When will fossil fuel reserves be diminished? Energ. Policy. 37, 181-189.

Shortall O.K. and Barnes A.P. ( 2013). Greenhouse gas emissions and the technical efficiency of dairy farmers. Ecol. Indicat. 29, 478-488.

Statistics Centre of Iran. (2014). Available at: http://www.amar.org.ir.

Stokes J., Tozer P.R. and Hyde J. (2007). Identifying efficient dairy producers using data envelopment analysis. J. Dairy Sci. 90, 2555-2562.

Theodoridis A.M. and Psychoudakis A. (2005). Efficiency measurement in greek dairy farms: stochastic frontiers. Data envelopment analysis. Int. J. Econ. Sci. Appl. Res. 1(2), 53-67.

Ubbels J. and Bouman S. (1979). The saving of energy when cooling milk and heating water on farms. Int. J. Ref. 2(1), 11-16.

Upton J., Humphreys J., Groot- Koerkamp P.W.G., French P., Dillon P. and De-Boer I.J.M. (2013). Energy demand on dairy farms in Ireland. J. Dairy Sci. 96(10), 6489-6498.

Upton J., Murphy M., French P. and Dillon P. (2010). Dairy farm energy consumption. Pp. 87-97 in Teagasc Nation. Dairy Conf. Mullingar, Ireland.

Uzmay A., Koyubenbe N. and Armagan G. (2009). Measurement of efficiency using data envelopment analysisand social factors affecting the technical efficiency in dairy cattle farms within the province of Izmir, Turkey. J. Anim. Vet. Adv. 8(6), 1110-1115.

Veysset P., Lherm M. and Bébin D. (2010). Energy consumption, greenhouse gas emissions and economic performance assessments in French Charolais suckler cattle farms: Model-based analysis and forecasts. Agric. Sys. 103, 41-50.

Yaldiz O., Zeren Y. and Bascetomcelik A. (1993). Energy usage in production of field crops in Turkey. Pp. 9 in Proc. 5^th Int. Cong. Mechan. Energ. Agric. Kusadasi, Turkey.

Zucchetto J. and Bickle G. (1984). Energy and nutrient analyses of a dairy farm in central Pennsylvania. Energ. Agric. 3, 29-47.