Effect of A. bisporus Mushroom Processing on Qualitative, Nutritional and Quality Characteristics
محورهای موضوعی : Research On Crop EcophysiologyMehrdad Jafarpour 1 , Mehrnoosh Kahvaei 2 , Davoud Ahmadi 3
1 - 1- Associate Professor, Department of Horticultural Sciences, Faculty of Agriculture, Islamic Azad University, Isfahan (Khorasgan) Branch
2 - Edible and Medicinal Mushroom Research Center, Islamic Azad University, Isfahan (Khorasgan) Branch
3 - MSc., Department of Agriculture and Food Security, Newcastle University, Newcastle upon Tyne, United Kingdom
کلید واژه: Keywords: Infrared, Canning, Shrinkage, Color indices, Amino acids,
چکیده مقاله :
Effect of A. bisporus Mushroom Processing on Qualitative, Nutritional and Quality Characteristics MEHRDAD JAFARPOUR1,2, MEHRNOOSH KAHVAEI2, DAVOUD AHMADI3 1- Associate Professor, Department of Horticultural Sciences, Faculty of Agriculture, Islamic Azad University, Isfahan (Khorasgan) Branch 2- Edible and Medicinal Mushroom Research Center, Islamic Azad University, Isfahan (Khorasgan) Branch 3-MSc., Department of Agriculture and Food Security, Newcastle University, Newcastle upon Tyne, United Kingdom * Corresponding author E-mail: mehrdad.jafarpour@gmail.com Received: 15 October 2023 Accepted: 25January 2024 ABSTRACT The processing of agricultural products or processing activities is crucial in developing the fruit and vegetable industry, increasing the marketability of fresh produce, and reducing post-harvest waste. This study evaluated the effect of different processing and drying methods (Such as salting, canning, infrared, and hot air) on the quality characteristics of A. bisporus mushroom. The maximum shrinkage ratio was achieved through the infrared treatment, with a value of 6.66 mm, while the lowest was obtained in the salting treatment, with a value of 1.17 mm. The highest fat content was observed in hot air treatment at 5.33%, while the lowest amount was obtained in the canning and salting treatments at 0.66% and 1%, respectively. The highest browning index was reported in the canning treatment, while the lowest was in the infrared and hot air treatments. The highest color change was found in the canning treatment, with a value of 21.45, while the lowest rate was observed in the infrared and hot air treatments, with values of 6.63 and 10.22, respectively. The highest color index of L* was observed in the control, infrared, and hot air treatments. However, the lowest amount was illustrated in the canning treatment. The highest color index of a* was observed in the canning treatment, with a rate of 12.93, while the lowest was found in the infrared, hot air, and control treatments. The highest color index of b* was observed in the salting and canning treatments. On the contrary, the lowest amount was indicated through the control, infrared, and hot air treatments. In general, the study results revealed that the infrared and hot air treatments significantly impacted the improvement of the color indices. Also, the canning treatment preserved the fat content and prevented its excessive oxidation in the A. bisporus mushrooms.
Effect of A. bisporus Mushroom Processing on Qualitative, Nutritional and Quality Characteristics MEHRDAD JAFARPOUR1,2, MEHRNOOSH KAHVAEI2, DAVOUD AHMADI3 1- Associate Professor, Department of Horticultural Sciences, Faculty of Agriculture, Islamic Azad University, Isfahan (Khorasgan) Branch 2- Edible and Medicinal Mushroom Research Center, Islamic Azad University, Isfahan (Khorasgan) Branch 3-MSc., Department of Agriculture and Food Security, Newcastle University, Newcastle upon Tyne, United Kingdom * Corresponding author E-mail: mehrdad.jafarpour@gmail.com Received: 15 October 2023 Accepted: 25January 2024 ABSTRACT The processing of agricultural products or processing activities is crucial in developing the fruit and vegetable industry, increasing the marketability of fresh produce, and reducing post-harvest waste. This study evaluated the effect of different processing and drying methods (Such as salting, canning, infrared, and hot air) on the quality characteristics of A. bisporus mushroom. The maximum shrinkage ratio was achieved through the infrared treatment, with a value of 6.66 mm, while the lowest was obtained in the salting treatment, with a value of 1.17 mm. The highest fat content was observed in hot air treatment at 5.33%, while the lowest amount was obtained in the canning and salting treatments at 0.66% and 1%, respectively. The highest browning index was reported in the canning treatment, while the lowest was in the infrared and hot air treatments. The highest color change was found in the canning treatment, with a value of 21.45, while the lowest rate was observed in the infrared and hot air treatments, with values of 6.63 and 10.22, respectively. The highest color index of L* was observed in the control, infrared, and hot air treatments. However, the lowest amount was illustrated in the canning treatment. The highest color index of a* was observed in the canning treatment, with a rate of 12.93, while the lowest was found in the infrared, hot air, and control treatments. The highest color index of b* was observed in the salting and canning treatments. On the contrary, the lowest amount was indicated through the control, infrared, and hot air treatments. In general, the study results revealed that the infrared and hot air treatments significantly impacted the improvement of the color indices. Also, the canning treatment preserved the fat content and prevented its excessive oxidation in the A. bisporus mushrooms.
REFERENCES
Adak N, Heybeli N, Ertekin C. 2017. Infrared drying of strawberry. Food Chemistry, 219: 109-116.
Aliaño-González MJ, Barea-Sepúlveda M, Espada-Bellido E, Ferreiro-González M, López-Castillo JG, Palma M, Barbero GF, Carrera C. 2022. Ultrasound-assisted extraction of total phenolic compounds and antioxidant activity in mushrooms. Agronomy, 12: 1812.
Aniesrani Delfiya DS, Prashob K, Mural S, Alfiya PV, Samuel MP, Pandiselvam R. 2021. Drying kinetics of food materials in infrared radiation drying: A review. Journal of Food Process Engineering, 2021: e13810, pp: 1-19.
Aprajeeta J, Gopirajah R, Anandharamakrishnan C. 2015. Shrinkage and porosity effects on heat and mass transfer during potato drying. Journal of Food Engineering, 144: 119–128.
Benoutman A, Erbiai EH, Edderdaki FZ, Cherif EK, Saidi R, Lamrani Z, Pintado M, Pinto E, Esteves da Silva JCG, Maouni A. 2022. Phytochemical composition, antioxidant and antifungal activity of Thymus Capitatus, a medicinal plant collected from Northern Morocco. Antibiotics, 11: 681.
Bhatta S, Janezic TS, Ratti C. 2020. Freeze-drying of plant-based foods. Foods, 9: 87.
Biernacka B, Dziki D, Rudy S, Krzykowski A, Polak R, Dziki L. 2022. Influence of pretreatments and freeze-drying conditions of strawberries on drying kinetics and physicochemical properties. Processes, 10: 1588.
Bostani S, Asefi N. 2021. The effect of drying process on the physiochemical characteristics and quality of Basil leaf leaves. Journal of Food Technology and Nutrition, pp. 5- 16.
Cavusoglu S, Uzun Y, Yilmaz N, Ercisli S, Eren E, Ekiert H, Elansary HO, Szopa A. 2021. Maintaining the quality and storage life of button mushrooms (Agaricus bisporus) with gum, agar, sodium alginate, egg white protein, and lecithin coating. Journal of Fungi, 7: 614.
Cavusoglu S, Uzun Y, Yilmaz N, Ercisli S, Eren E, Ekiert H, Elansary HO, Szopa A. 2021. Maintaining the quality and storage life of button mushrooms (Agaricus bisporus) with gum, agar, sodium alginate, egg white protein, and lecithin coating. Journal of Fungi, 7: 614.
Chao J, Dai Y, Cheng HY, Lam W, Cheng YC, Li K, Peng WH, Pao LH, Hsieh MT, Qin XM. 2017. Improving the concentrations of the active components in the herbal tea ingredient, uraria crinita: The effect of post-harvest oven-drying processing. Scientific Reports, 7: 38763.
Chen Y, Cai W, Shi Y, Dong X, Bai F, Shen S, Jiao R, Zhang X, Zhu X. 2020. Effects of different salt concentrations and vacuum packaging on the shelf-stability of Russian sturgeon (Acipenser gueldenstaedti) stored at 4 °C. Food Control, 109: 106865
Chuensun T, Chewonarin T, Laopajon W, Kawee-ai A, Pinpart P, Utama-ang N. 2020. Comparative evaluation of physicochemical properties of Lingzhi (Ganoderma lucidum) as affected by drying conditions and extraction methods. Food Traceability and Security, 56: 2751-2759.
Coşkun S, Doymaz İ, Tunçkal C, Erdoğan S. 2017. Investigation of drying kinetics of tomato slices dried by using a closed loop heat pump dryer. Heat Mass Transfer, 53: 1863-1871.
Da Silva AC, Jorge N. 2014. Influence of Lentinus edodes and Agaricus blazei extracts on the prevention of oxidation and retention of tocopherols in soybean oil in an accelerated storage test. Journal of Food Science and Technology, 51: 1208-12.
Dawadi E, Magar PB, Bhandari S, Subedi S, Shrestha S, Shrestha J. 2022. Nutritional and post-harvest quality preservation of mushrooms: A review. Heliyon, 12: e12093.
De Araujo MEV, Barbosa EG, Lopes RP, Corrêa PC, Barbosa EG. 2021. Infrared drying of pear slices: drying kinetics, energy, and exergy analysis. Journal of Food Process Engineering, 44: e13915.
Duan X, Miao J, Huang L, Li B. 2022. Microwave freeze-drying of button mushroom (Agaricus bisporus) based on nonvolatile taste components by controlling microwave power density. International Journal of Food Science and Technology, 57: 379-389.
Duan X, Miao J, Huang L, Li B. 2022. Microwave freeze-drying of button mushroom (Agaricus bisporus) based on nonvolatile taste components by controlling microwave power density. International Journal of Food Science and Technology, 57: 379-389.
Ebadi MT, Sefidkon F, Azizi M, Ahmadi N. 2016. Effects of air velocity and infrared radiation intensity on drying factors of lemon verbena (Lippia citriodora Kunth.). Iranian Journal of Medicinal and Aromatic Plants Research, 32: 161-173.
Elmastas M, Isildak O, Turkekul I, Temur N. 2007. Determination of antioxidant activity and antioxidant compounds in wild edible mushrooms. Journal of Food Composition and Analysis, 20: 337–345.
Erbiai EH, Maouni A, Pinto da Silva L, Saidi R, Legssyer M, Lamrani Z, Esteves da Silva JCG. 2023. Antioxidant properties, bioactive compounds contents, and chemical characterization of two wild edible mushroom species from Morocco: Paralepista flaccida (Sowerby) Vizzini and Lepista nuda (Bull.) cooke. Molecules, 28: 1123.
Esmaeili Y, Zamindar N, Mohammadi R. 2023. The effect of polypropylene film containing nano-hydroxyapatite on Physicochemical and microbiological properties of button mushrooms (Agaricus bisporus) under Modified atmosphere packaging. Journal of Food Measurement, 17: 773–786.
Farias Menezes TM, Campelo MS, Nogueira Lima AB, Câmara Neto JF, Morais Saraiva M, Costa de Sousa JA, Costa Gonzaga ML, Moreira Leal LKA, Pinho Ribeiro MEN, Silva Ricardo NMP, Aguiar Soares S. 2022. Effects of polysaccharides isolated from mushrooms (Lentinus edodes Berk or Agaricus blazei Murill) on the gelation of Pluronic® F127. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 642: 128684.
Feng Y, Tan CP, Zhou C, Yagoub AEA, Xu B, Sun Y. 2020. Effect of freeze-thaw cycles pretreatment on the vacuum freeze-drying process and physicochemical properties of the dried garlic slices. Food Chemistry, 324: 10.1016/j.foodchem.2020.126883
Gao R, Yu Q, Shen Y, Chu Q, Chen G, Fen S, Yang M, Yuan L, McClements DJ. Sun Q. 2021. Production, bioactive properties and potential application of fish protein hydrolysates: Developments and challenges. Trends in Food Science and Technology, 110: 687-699.
Geng Z, Wang H, Torki M, Beigi M, Zhu L, Huang X, Yang X, Hu B. 2023. Thermodynamically analysis and optimization of potato drying in a combined infrared/convective dryer. Case Studies in Thermal Engineering, 42: 102671.
Golpour I, Kaveh M, Blanco-Marigorta AM, Marcos JD, Guiné RPF, Amiri Chayjan R, Khalife E, Karami H. 2022. Multi-Response design optimisation of a combined fluidised bed-infrared dryer for terebinth (Pistacia atlantica L.) fruit drying process based on energy and exergy assessment by applying RSM-CCD modelling. Sustainability, 14: 15220.
Gulati T, Datta AK. 2015. Mechanistic understanding of case-hardening and texture development during drying of food materials. Journal of Food Engineering, 166: 119–138.
Guo Y, Chen X, Gong P, Wang R, Qi Z, Deng Z, Han A, Long H, Wang J, Yao W. 2023. Advances in post-harvest storage and preservation strategies for Pleurotus eryngii. Foods, 12: 1046.
Hu L, Bi J, Jin X, Qiu Y, Sman RGM. 2021. Study on the rehydration quality improvement of Shiitake mushroom by combined drying methods. Foods, 10: 769.
Huang K, El-Seedi HR, Xu B. 2022. Critical review on chemical compositions and health-promoting effects of mushroom Agaricus blazei Murill. Current Research in Food Science, 5: 2190–2203.
Huang Q, Qian X, Jiang T, Zheng X. 2019. Effect of chitosan and guar gum based composite edible coating on quality of mushroom (Lentinus edodes) during post-harvest storage. Scientia Horticulturae, 253: 382–389.
Inyang UE, Oboh IO, Etuk BR. 2018. Kinetic Models for Drying Techniques—Food Materials. Advances in Chemical Engineering and Science, 8: 27–48
Iranshahi K, Rubinetti D, Onwude DI, Psarianos M, Schlüter OK, Defraeye Th. 2023. Electrohydrodynamic drying versus conventional drying methods: A comparison of key performance indicators. Energy Conversion and Management, 279: 116661.
Jan I, Rab A, Sajid M, Ali A, Shah S. 2012. Response of apple cultivars to different downloaded from storage durations. Sarhad Journal of Agriculture, 28: 219-225.
Jaworska G, Bernas E, Mickowska B. 2011. Effect of production process on the amino acid content of frozen and canned Pleurotus ostreatus mushrooms. Food Chemistry, 125: 936–943.
Jiang L, Yu Z, Lin Y, Cui L, Yao S, Lv L, Liu J. 2018. Low-molecular-weight polysaccharides from Agaricus blazei Murrill modulate the Th1 response in cancer immunity. Oncology Letters, 15: 3429–3436.
Jiang T. 2013. Effect of alginate coating on physicochemical and sensory qualities of button mushrooms (Agaricus bisporus) under a high oxygen modified atmosphere. Post-harvest Biology and Technology, 76: 91-97.
Joardder MUH, Brown RJ, Kumar C, Karim MA. 2015. Effect of cell wall properties on porosity and shrinkage of dried apple. Journal of Food Properties, 18: 2327–2337.
Joardder MUH, Kumar C, Karim MA. 2018. Prediction of porosity of food materials during drying: Current challenges and directions. Critical Reviews in Food Science and Nutrition, 58: 2896–2907.
Kannan A, Neeharika K. 2014. Estimation of energy consumption in thermal sterilization of canned liquid foods in still retorts. Engineering Applications of Computational Fluid Mechanics, 4: 288–303.
Kantrong H, Tansakul A, Mittal GS. 2014. Drying characteristics and quality of shiitake mushroom undergoing microwave-vacuum drying and microwave-vacuum combined with infrared drying. Journal of Food Science and Technology, 51: 3594-3608.
Karunasena HCP, Senadeera W, Brown RJ, Gu YTA. 2014. Particle based model to simulate microscale morphological changes of plant tissues during drying. Soft Matter, 10: 5249– 5268.
Kaveh M, Jahanbakhshi A, Askari AsliArdeh E, Imanian K. 2019. Sour lemon drying by hot air drying under ultrasonic pretreatmen. Journal of Research and Innovation in Food Science and Technology, 6: 233-245.
Kayran S, Doymaz I. 2019. Infrared drying of apricot pomace. Latin American Applied Research, 49: 213-218.
Kıan-pour N. 2020. Fundamental drying techniques applied in food science and technology. International Journal of Food Engineering Research, 6: 35–63
Kocabiyik H, Yilmaz N, Tuncel NB, Sumer SK, Buyukcan MB. 2015. Drying, energy, and some physical and nutritional quality properties of tomatoes dried with short-infrared radiation. Food and Bioprocess Technology, 8: 516-525.
Kothari D, Patel S, Kim SK. 2018. Anticancer and other therapeutic relevance of mushroom polysaccharides: A holistic appraisal. Biomedicine and Pharmacotherapy, 105: 377–394.
Kręcisz M, Kolniak-Ostek J, Łyczko J, Stępień B. 2023. Evaluation of bioactive compounds, volatile compounds, drying process kinetics and selected physical properties of vacuum impregnation celery dried by different methods. Food Chemistry, 413: 135490.
Krzykowski A, Dziki D, Rudy S, Polak R, Biernacka B, Gawlik-Dziki U, Janiszewska-Turak E. 2023. Effect of air-drying and freeze-drying temperature on the process kinetics and physicochemical characteristics of white mulberry fruits (Morus alba L.). Processes, 11: 750.
Kumar C, Joardder MUH, Farrell TW, Karim MA. 2018. Investigation of intermittent microwave convective drying (IMCD) of food materials by a coupled 3d electromagnetics and multiphase model. Drying Technology, 36: 736–750.
Li W, Li R, Chen W, Feng J, Wu D, Zhang Z, Zhang J, Yang Y. 2022. The anabolism of sulphur aroma volatiles responds to enzymatic and non-enzymatic reactions during the drying process of shiitake mushrooms. Food Chemistry, 371: 131123.
Lin Q, Lu Y, Zhang J, Liu W, Guan W, Wang Z. 2017. Effects of high CO2 in-package treatment on flavor, quality and antioxidant activity of button mushroom (Agaricus bisporus) during post-harvest storage. Post-harvest Biology and Technology, 123: 112–118.
Liu C, Sheng J, Chen L, Zheng Y, Lee DYW, Yang Y, Xu M, Shen L. 2015. Biocontrol activity of Bacillus subtilis isolated from Agaricus bisporus mushroom compost against pathogenic fungi. Journal of Agricultural and Food Chemistry, 63: 6009–6018.
Liu J, Jia L, Kan J, Jin C. 2013. In vitro and in vivo antioxidant activity of ethanolic extract of white button mushroom (Agaricus bisporus). Food and Chemical Toxicology, 51: 310–316.
Llave Y, Takemori K, Fukuoka M, Takemori T, Tomita H, Sakai N. 2016. Mathematical modeling of shrinkage deformation in eggplant undergoing simultaneous heat and mass transfer during convection-oven roasting. Journal of Food Engineering, 178: 124–136.
Mahiuddin M, Khan MIH, Kumar C, Rahman MM, Karim MA. 2018. Shrinkage of food materials during drying: current status and challenges. Comprehensive Reviews in Food Science and Food Safety, 17: 1113–1126.
Marçal S, Sousa AS, Taofiq O, Antunes F, Morais AM, Freitas AC, Barros L, Ferreira IC, Pintado M. 2021. Impact of post-harvest preservation methods on nutritional value and bioactive properties of mushrooms. Trends in Food Science & Technology, 110: 418–431.
Martin-Belloso O, Lianos-Barriobero E. 2001. Proximate composition, minerals and vitamins in selected canned vegetables. European Food Research and Technology, 212: 182–187.
Martysiak-Zurowska D, Rozek P, Puta M. 2020. The effect of freeze-drying and storage on lysozyme activity, lactoferrin content, superoxide dismutase activity, total antioxidant capacity and fatty acid profile of freeze-dried human milk. Drying Technology, 2020: 1–11
Mercier S, Villeneuve S, Mondor M, Des Marchais LP. 2011. Evolution of porosity, shrinkage and density of pasta fortified with pea protein concentrate during drying. LWT - Food Science and Technology, 44: 883–890.
Mierzwa D, Pawłowski A. 2017. Convective drying of potatoes assisted by microwave and infrared radiation–process kinetics and quality aspects. Journal of Food and Nutrition Research, 56: 351-361.
Mirzaei S, Ameri M, Ziaforoughi A. 2021. Energy-exergy analysis of an infrared dryer equipped with a photovoltaicthermal collector in glazed and unglazed modes. Renewable Energy, 169: 541-556.
Misgiati M, Sukardiman S, Widyawaruyanti A. 2017. Anti-breast cancer potency of multistage extraction from jamur dewa (Agaricus blazei Murill) solvents on MCF-7 cells. Indonesian Journal of Cancer Chemoprevention, 8: 68-73.
Monirujamman M. 2014. Metabolic and physiological roles of branched chain amino acids. Advances in Molecular Biology, 2014: 364976
Motevali A, Jafari H, Hashemi JS. 2018. Effect of IR intensity and air temperature on exergy and energy at hybrid infrared-hot air dryer. Chemical Industry & Chemical Engineering Quarterly, 24: 31-42.
Nketia S, Buckman ES, Dzomeku M, Akonor PT. 2020. Effect of processing and storage on physical and texture qualities of oyster mushrooms canned in different media. Scientific African, 9: e00501.
Parmar N, Singh N, Kaur A, Virdi AS, Thakur S. 2016. Effect of canning on color, protein and phenolic profile of grains from kidney bean, field pea and chickpea. Food Research International, 89: 526-532.
Parmar N, Singh N, Kaur A, Virdi AS, Thakur S. 2016. Effect of canning on color, protein and phenolic profile of grains from kidney bean, field pea and chickpea. Food Research International, 89: 526-532.
Piskov S, Timchenko L, Grimm WD, Rzhepakovsky I, Avanesyan S, Sizonenko M, Kurchenko V. 2020. Effects of various drying methods on some physico-chemical properties and the antioxidant profile and ace inhibition activity of oyster mushrooms (Pleurotus Ostreatus). Foods, 9: 160
Pogoń K, Gabor A, Jaworska G, Bernaś E. 2017. Effect of traditional canning in acetic brine on the antioxidants and vitamins in boletus edulis and suillus luteus mushrooms. Journal of Food Processing and Preservation, 41: doi:10.1111/jfpp.12826.
Praneetpolkrang P, Sathapornprasath K. 2021. Thin-layer drying model of jackfruit using artificial neural network in a far infrared dryer. Engineering and Applied Science Research, 48: 181–189.
Pursito DJ, Purnomo EH, Fardiaz D, Hariyadi P. 2022. Effect of sterility values and retort temperatures on the antioxidant activities, soluble protein, and pH of canned mushroom. Current Research in Nutrition and Food Science, 10: 553-565.
Qin L, Gao JX, Xue J, Chen D, Lin SY, Dong XP, Zhu BW. 2020. Changes in aroma profile of shiitake mushroom (Lentinus edodes) during different stages of hot air drying. Foods, 9: 444, doi:10.3390/foods9040444.
Reis FR, Marques C. de Moraes ACS, Masson ML. 2022. Trends in quality assessment and drying methods used for fruits and vegetables. Food Control, 142: 109254
Rekik C, Besombes C, Hajji W, Gliguem H, Bellagha S, Mujumdar AS, Karim Allaf K. 2021. Study of interval infrared airflow drying: A case study of butternut (Cucurbita moschata). LWT - Food Science and Technology, 147: 111486.
Reshmi NP, Mandal G, Thokchom R. 2018. Effect of pre-treatment of salt solution and drying methods on the quality of processed aonla (Emblica officinalis Gaertn.). International Journal of Current Microbiology and Applied Sciences, 7: 1438-1446.
Salehi F. 2020. Recent applications and potential of infrared dryer systems for drying various agricultural products: A review. International Journal of Fruit Science, 20: 586-602.
Santi-Rampazzo AP, Schoffen JP, Cirilo CP, Zapater MC, Vicentini FA, Soares AA. 2015. Aqueous extract of Agaricus blazei Murrill prevents age-related changes in the myenteric plexus of the jejunum in rats. Evidence-Based Complementary and Alternative Medicine, 2015: 01-13.
Savas E. 2022. The modelling of convective drying variables’ effects on the functional properties of sliced sweet potatoes. Foods, 11: 741.
Sério S, Rivero -Pèrez MD, Correia AC, Jordao AM, Gonzàlez -San Josè ML. 2014. Analysis of commercial grape raisins: Phenolic content, antioxidant capacity and radical scavenger activity. Ciência e Técnica Vitivinícola, 29: 1 -8.
Song F, Li Z, Raghavan GSV. 2017. Combined microwave–hot-air drying of burdock slices with feedback temperature control at surface and core. Drying Technology, 35: 1781-1790.
Stevanato N, Ribeiro TH, Giombelli C. 2020. Effect of canning on the antioxidant activity, fiber content, and mechanical properties of different parts of peach palm heart. Journal of Food Processing and Preservation, 44: e14554.
Sun M, Ni L, Huang Y, Yang M, Cheng G, Zhang M, Wu M, Ma C. 2023. Effects of different drying treatments on the microstructure, free amino acids, volatile compounds and antioxidant activity of Flammulina velutipes root. Food Chemistry, 18: 100656.
Szadzińska J, Mierzwa D, Musielak G. 2022. Ultrasound-assisted convective drying of white mushrooms (Agaricus bisporus). Chemical Engineering and Processing - Process Intensification, 172: 108803.
Tang Y, Chen G, Wang D, Hu R, Li H, Liu S, Zhang Q, Ming J, Chi Y. 2022. 2022. Effects of dry-salting and brine-pickling processes on the physicochemical properties, nonvolatile flavour profiles and bacterial community during the fermentation of Chinese salted radishes. LWT - Food Science and Technology, 157: 113084.
Tao Y, Zhang J, Jiang S, Xu Y, Show PL, Han Y, Ye X, Ye M. 2018. Contacting ultrasound enhanced hot-air convective drying of garlic slices: Mass transfer modeling and quality evaluation. Journal of Food Engineering, 235: 79-88.
Tetteh ONA, Ulrichs C, Huyskens-Keil S, Mewis I, Amaglo NK, Oduro IN, Adarkwah C, Obeng-Ofori D, Förster N. 2019. Effects of harvest techniques and drying methods on the stability of glucosinolates in Moringa oleifera leaves during post-harvest. Scientia Horticulturae, 246: 998–1004.
Tian Y, Zhao Y, Huang J, Zeng H, Zheng B. 2016. Effects of different drying methods on the product quality and volatile compounds of whole shiitake mushrooms. Food Chemistry, 197: 714-722.
Timm NS, Lang GH, Ferreira CD, Pohndorf RS, Oliveira M. 2020. Infrared radiation drying of parboiled rice: Influence of temperature and grain bed depth in quality aspects. Journal of Food Process Engineering, 43: e13375. https://doi.org/10.1111/jfpe.13375.
Torki-Harchegani M, Ghasemi-Varnamkhasti M, Ghanbarian D, Sadeghi M, Tohidi M. 2016. Dehydration characteristics and mathematical modelling of lemon slices drying undergoing oven treatment. Heat and Mass Transfer, 52: 281-289.
Victor WC, Obele S. 2013. The effect of brine solution on mushroom (Pleurotus ostreatus) preserved at room temperature (26- 300C). Greener Journal of Agricultural Sciences, 3: 445-447.
Wang H, Zhang M, Adhikari B. 2015. Drying of shiitake mushroom by combining freeze-drying and mid-infrared radiation. Food and Bioproducts Processing, 94: 507-517.
Wang H, Zhang M, Mujumdar AS. 2014. Comparison of three new drying methods for drying characteristics and quality of Shiitake mushroom (Lentinus edodes). Drying Technology: An International Journal, 32: 1791-1802.
Wang J, Wu J, Ogura R, Kobori H, Choi JH, Hirai H, Takikawa Y, Kawagishi H. 2022. Anti-phytopathogenic-bacterial fatty acids from the mycelia of the edible mushroom Agaricus blazei. Bioscience Biotechnology and Biochemistry, zbac117, https://doi.org/10.1093/bbb/zbac117.
Wang Y, Li T, Pan Z, Ye X, Ma H. 2023. Effectiveness of combined catalytic infrared radiation and holding time for decontamination Aspergillus niger on dried shiitake mushrooms (Lentinus edodes) with different moisture contents. LWT - Food Science and Technology, 176: 114503.
Wen YX, Chen LY, Li BS, Ruan Z, Pan Q. 2021. Effect of infrared radiation-hot air (IR-HA) drying on kinetics and quality changes of star anise (Illicium verum). Drying Technology, 39: 90–103.
Wongsa P, Bhuyar P, Tongkoom K. 2023. Influence of hot-air drying methods on the phenolic compounds/allicin content, antioxidant activity and α-amylase/α-glucosidase inhibition of garlic (Allium sativum L.). European Food Research and Technology, 249: 523–535.
Workneh TS, Zinash A, Woldetsadik K. 2014. Blanching, salting and sun drying of different pumpkin fruit slices. Journal of Food Science and Technology, 51: 3114–3123.
Wu X, Zhang M, Bhandari B. 2019. A novel infrared freeze drying (IRFD) technology to lower the energy consumption and keep the quality of Cordyceps militaris. Innovative Food Science & Emerging Technologies, 54: 34-42.
Xi J, Chen X, Du J, Zhong L, Hu Q, Zhao L. 2023. Biosynthesis, behavior and fate of volatile organic sulfide in Lentinus edodes (Berk.) upon hot-air drying treatment. Food Chemistry, 412: 135528.
Xu L, Fang X, Wu W, Chen H, Mu H, Gao H. 2019. Effects of high-temperature pre-drying on the quality of air-dried shiitake mushrooms (Lentinula edodes). Food Chemistry, 285: 406-413.
Xue Z, Hao J, Yu W, Kou X. 2016. Effects of processing and storage preservation technologies on nutritional quality and biological activities of edible fungi: a review. Journal of Food Process Engineering, pp: 1-13.
Yang LH, Liu LD, Wang XJ, Qu HG, Ma QH, Cai DH. 2007. Effects of salting on extraction of Agaricus bisporus polysaccharides. Food Science, 10: 151–154.
Yang RL, Li Q, Hu QP. 2020. Physicochemical properties, microstructures, nutritional components, and free amino acids of Pleurotus eryngii as afected by diferent drying methods. Scientific Reports, 10:121
Yang XH, Deng LZ, Mujumdar AS, Xiao HW, Zhang Q, Kan Z. 2018. Evolution and modeling of colour changes of red pepper (Capsicum annuum L.) during hot air drying. Journal of Food Engineering, 231: 101-108.
Zadhossein S, Abbaspour-Gilandeh Y, Kaveh M, Nadimi M, Paliwal J. 2023. Comparison of the energy and exergy parameters in cantaloupe (Cucurbita maxima) drying using hot air. Smart Agricultural Technology, 4: 100198.
Zhang L, Dong X, Feng X, Ibrahim SA, Huang W, Liu Y. 2021. Effects of drying process on the volatile and nonvolatile flavor compounds of Lentinula edodes. Foods, 10: 2836.
Zhao X, Wei Y, Gong X, Xu H, Xin G. 2020. Evaluation of umami taste components of mushroom (Suillus granulatus) of different grades prepared by different drying methods. Food Science and Human Wellness, 9: 192-198.
Zou XG, Chi Y, Cao YQ, Zheng M, Deng ZY, Cai M, Yang K, Sun PL. 2023. Preparation process optimization of peptides from Agaricus blazei Murrill, and comparison of their antioxidant and immune-enhancing activities separated by ultrafiltration
Research on Crop Ecophysiology Vol.19/1, Issue 1 (2024), Pages: 44 - 63
|
Original Research |
Effect of A. bisporus Mushroom Processing on Qualitative, Nutritional and Quality Characteristics
Mehrdad Jafarpour1,2, Mehrnoosh Kahvaei2, Davoud Ahmadi3
1- Associate Professor, Department of Horticultural Sciences, Faculty of Agriculture, Islamic Azad University, Isfahan (Khorasgan) Branch
2- Edible and Medicinal Mushroom Research Center, Islamic Azad University, Isfahan (Khorasgan) Branch
3-MSc., Department of Agriculture and Food Security, Newcastle University, Newcastle upon Tyne, United Kingdom
* Corresponding author E-mail: mehrdad.jafarpour@gmail.com
Received: 15 October 2023 Accepted: 25January 2024
Abstract
The processing of agricultural products or processing activities is crucial in developing the fruit and vegetable industry, increasing the marketability of fresh produce, and reducing post-harvest waste. This study evaluated the effect of different processing and drying methods (Such as salting, canning, infrared, and hot air) on the quality characteristics of A. bisporus mushroom. The maximum shrinkage ratio was achieved through the infrared treatment, with a value of 6.66 mm, while the lowest was obtained in the salting treatment, with a value of 1.17 mm. The highest fat content was observed in hot air treatment at 5.33%, while the lowest amount was obtained in the canning and salting treatments at 0.66% and 1%, respectively. The highest browning index was reported in the canning treatment, while the lowest was in the infrared and hot air treatments. The highest color change was found in the canning treatment, with a value of 21.45, while the lowest rate was observed in the infrared and hot air treatments, with values of 6.63 and 10.22, respectively. The highest color index of L* was observed in the control, infrared, and hot air treatments. However, the lowest amount was illustrated in the canning treatment. The highest color index of a* was observed in the canning treatment, with a rate of 12.93, while the lowest was found in the infrared, hot air, and control treatments. The highest color index of b* was observed in the salting and canning treatments. On the contrary, the lowest amount was indicated through the control, infrared, and hot air treatments. In general, the study results revealed that the infrared and hot air treatments significantly impacted the improvement of the color indices. Also, the canning treatment preserved the fat content and prevented its excessive oxidation in the A. bisporus mushrooms.
Keywords: Infrared, Canning, Shrinkage, Color indices, Amino acids
Introduction
Fresh vegetables and fruits contain high amount of moisture, with approximately 80% of their weight being water, creating ideal circumstances for microbiological and enzyme activities that contribute to rapid spoilage during the post-harvest period (Mat Desa et al., 2015). Food spoilage has long been a concern for humans as it can lead to various diseases, even death, and financial losses (Joardder et al., 2018). To address this issue, humans have developed methods to slow down the food spoilage process and extend the storage time of food (Biernacka et al., 2022). Initially, by understanding some of the causes of food spoilage, such as temperature, the natural factors were used to prolong the storage time of the food (Cavusoglu et al., 2015). However, with the advancements in knowledge and industry, these methods have constantly evolved to become more complex and efficient. Processing of agricultural products or processing activities is crucial in the development of fruit and vegetable industry, increasing the marketability of new products and reducing post-harvest waste (Krzykowski et al., 2023). Due to the growing trend of population, food supply has become a major concern for the world. Moreover, population growth and rising costs of food, particularly high-quality protein sources, have further emphasized the importance of agricultural food resources (Zhao et al., 2020). Today, edible mushroom cultivation has become increasingly important worldwide, with significant progress being made in this sector. According to the Food and Agriculture Organization (FAO), global mushroom production reached about 11 million tons in 2020, with Iran contributing 180 thousand tons to this total (Fartash Naeimi et al., 2020).
High amount of moisture in the products plays a crucial role in their storage. Drying, as one of the conventional and old methods, is used to extend the shelf life of agricultural products (Hargoindigo and Fisour, 2019) by reducing the moisture in the foods, slowing down the microbial spoilage and chemical changes and subsequently, increasing the storage time as well as reducing the required space and weight (Tetteh et al., 2019). This process involves extracting existing water in a food through evaporation or sublimation using a thermal source under controlled and precise conditions (Bhatta et al., 2020). In order to prevent thermal and moisture stresses that could lead to quantitative and qualitative losses of the product, strict controls on the drying process are necessary (Wang et al., 2023).
Despite the important advantages of drying in the processing and preserving of agricultural and food products, using incorrect methods and applying unfavorable conditions can lead to quality loss and decreased final product value, as well as increased time, money, and energy consumption. In fact, the biggest challenge of drying industry is to produce a high-quality product at a minimum cost (Hu et al., 2020). Thus, evaluating the consumed energy and quality of the final product is necessary to determine the optimal drying conditions for each product. The purpose of this Study the impact of different drying methods and conditions on the consumed energy in the drying process of various products are also important for researchers.
Materials and Methods
Uniform A. bisporus mushrooms without any stain, disease, etc., were selected and transferred to the Edible and Medicinal Mushroom Research Center, Islamic Azad University, Isfahan (Khorasgan) Branch. Fresh mushrooms were stored in the fridge at 4 °C with a relative humidity of 95% prior to the test. The samples were washed with cold water to remove the sticky soil particles, dispose of compost residues on mushrooms, and reduce the microbial load. This step was done as fast as possible to prevent the absorption of extra water. Mushrooms were cut into 5±1 mm thick using a sharp steel knife after manually removing the extra water from the surface. Mushroom slices were placed on one layer of special steel trays and then transferred to the drying device.
Treatments / Hot air
The fruit body of the sliced A. bisporus mushroom (all 5000 grams) was placed on the steel trays. Then, the mushrooms were dried using the electric thermal drier at 55 °C for 4 hours so that the moisture content of the samples reached the moist base of 10 grams per 100 grams (Hu et al., 2020).
Infrared
The sample mushrooms were dried under the infrared rays at 35 °C with a short wavelength (Hu et al., 2021). The infrared lamps were placed in a row on the upper surface of the dryer chamber, emitting infrared radiation in the range of medium to short wavelengths (2.3-3 µm). The maximum power of each lamp was 450 watts, and the radiation efficiency was 70-80%. To ensure the uniform radiant heating, 6 IR lamps were turned on with a maximum power of 1.2 kW. The distance between the infrared lamps and the trays containing the mushroom samples was 14 cm (Wang et al., 2015).
Canning
180 grams of A. bisporus mushroom were placed in 300cm3 glass containers, sealed, and sterilized with 100 cm3 of hot solution containing 2% salt through aerated immersion. The sterilization process was as follows: increasing the temperature up to 100 °C for 5 minutes, increasing the temperature from 100 to 118 °C for 10 minutes, sterilizing at 118 to 121 °C for 12 minutes, and finally, cooling at 30 °C for 10 minutes. Then, the canned mushrooms were stored at 8-10 °C (Jawroska et al., 2011).
Salting
The sliced mushrooms were immersed in a 10% salt solution for 10 minutes (Workneh et al., 2014).
Measuring methods of the studied traitsFat
Fat content was calculated by extracting it from the sample using ether as a solvent in the Soxhlet Extractor device (Shams et al., 2022).
Shrinkage
The thickness and Thickness Shrinkage Ratio (Sd) of the dried mushrooms were analyzed using the Vernier Scale at 0.05 mm accuracy (Shanghai Nine Volume Hardware Tools Co., LTD, China). Then, based on Equation (1), the Shrinkage ratio was evaluated in A. bisporus mushrooms under considered treatments. In this Equation, dt (mm) and d0 are the diameter and thickness of the dried and fresh mushrooms, respectively (Wang et al., 2014).
Equation (1)
Sd = d0 – dt/ d0 × 100
Color Indices Measurement
The color of samples was examined using a Hunterlab device after and before drying, and the color values were presented as L* (brightness), a* (redness), and b* (yellowness). Browning index (BI), which represents the purity of brown and is considered an essential factor of Browning, was measured based on Equation (4) ( Jiang, 2013).
Equation (4): BI= 100- (x-0.31)/0.172
Moreover, the color change (ΔE) of the samples treated with fresh mushrooms was obtained using Equation (5) (Jiang, 2013).
Equation (5):
ΔE= [(L-97)2 + (a-(-2))2+ b2]1/2
Results
The effect of the studied treatments on the qualitative features of A. bisporus Mushroom
The data analysis of variance showed that the effect of treatment on the shrinkage of A. bisporus mushrooms was significant at the probability level of 1% (Table 1). Comparing the mean of data showed that the effect of the studied treatments on the shrinkage in A. bisporus mushroom was significant at a 5% probability level of Duncan’s test, indicating the maximum shrinkage in Infrared ray treatment with a value of 6.66 mm, and the minimum shrinkage in salting treatment with the value of 1.17 mm. There was no statistically significant difference between canning and hot air treatments at the 5% probability level of Duncan's test (Figure 1).
Table 1. The results of variance analysis of the effect of studied treatments on quality characteristics of A. bisporus mushroom
| Mean Squares | |||||
Sum of squares | Degree of freedom | Shrinkage | Fat content | BI | EΔ | |
Treatment | 3 | 16.01** | 13.57** | 168.363** | 956.76** | |
experimental error | 8 | 0.42 | 0.07 | 455.65 | 32.84 | |
Coefficient of variations % |
| 14.07 | 11.18 | 24.96 | 24.26 | |
**: significant at 1% probability level | ||||||
Figure 1. Comparison between the means- the effect of different treatments on the shrinkage of A. bisporus mushrooms. Means with at least one letter in common do not have a significant difference at 5% probability level of Duncan's test.
The data analysis of variance showed that effect of the treatment on the fat content in A. bisporus mushroom was significant at 1% probability level (Table 1). The comparison between the data indicated that the effect of the studied treatments on the amount of fat content in A. bisporus mushrooms was significant at 5% probability level of Duncan’s test. This indicated a maximum fat of 5.33% in hot air treatment, while canning and salting treatments with the values of 0.66% and 1% were considered the minimum, respectively. Moreover, there was no significant difference between salting and canning treatments at 5% probability level of Duncan’s test.
Figure 2. Comparison between the means- the effect of different treatments on the fat content of A. bisporus mushrooms. Means with at least one letter in common do not have significant difference at 5% probability level of Duncan's test.
Browning Index (BI)
Data analysis of variance indicated that the effect of the treatment on the Browning index in A. bisporus mushrooms was significant at 1% probability level (Table 1). Comparing the means of data showed a significant difference in the impact of different treatments on the Browning index in A. bisporus mushrooms at 5% probability level of Duncan’s test. That is to say, the maximum Browning index was observed in canning treatment with the value of 140.66, while the minimum value was obtained in infrared rays and hot air treatments with the values of 25.79 and 32.42, respectively. There was no significant difference between the infrared rays and hot air treatments at 5% probability level of Duncan’s test (Figure 3).
Figure 3. Comparison between the means- the effect of different treatments on the Browning index in A. bisporus mushrooms. Means with at least one letter in common do not have significant difference at 5% probability level of Duncan's test.
Color Change (ΔE)
The data analysis of variance revealed that effect of the treatment on the color change in A. bisporus mushrooms was significant at 1% probability level (Table 1). Comparing the means of the data indicated that effect of the studied treatments on the color change in A. bisporus mushrooms was significant at 5% probability level of Duncan’s test. The maximum color change was observed in the canning treatment with the value of 45.21, while the minimum color change was seen in infrared rays and hot air treatments with values of 6.63 and 10.22, respectively. Furthermore, there was no significant difference between the infrared rays and hot air treatments at a 5% probability level of Duncan’s test (Figure 4).
Figure 4. Comparison between the means- the effect of different treatments on the amount of color change in A. bisporus mushrooms. Means with at least one letter in common do not have significant difference at 5% probability level of Duncan's test.
Color Index of L*
Data analysis of variance showed a significant difference in the impact of the treatment on a color index of L* in A. bisporus mushrooms at a 1% probability level (Table 2). The results of comparing the means of data represented that the effect of the studied treatments on the color index of L* in A. bisporus mushrooms was significant at a 5% probability level of Duncan’s test. Also, the maximum color index of L* was control, infrared rays, and hot air treatments with the values of 79.26, 78.16, and 74.66, respectively, and there was no significant difference between these treatments at a 5% probability level of Duncan’s test. The minimum value was observed in canning treatment with a value of 42.06 (Figure 5).
Table 2. Analysis of variance of the impact of the studied treatments on some quality features of A. bisporus mushrooms
| Mean Squared | |||
Sum of squares for error | Degree of freedom | L* | a* | b* |
Treatment | 4 | 74.241** | 99.95** | 191.30** |
experimental error | 10 | 13.19 | 2.71 | 29.05 |
Coefficient of variations % |
| 5.39 | 24.32 | 22.45 |
**: significant at 1% probability level | ||||
Figure 5. Comparison between the means- the effect of different treatments on the color index of L* in A. bisporus mushrooms. Means with at least one letter in common do not have a significant difference at 5% probability level of Duncan's test.
Color Index of a*
Data analysis of variance indicated a significant difference in the impact of the treatment on the color index of a* in A. bisporus mushrooms at a 1% probability level (Table 2). Comparison between the means of data revealed that the effect of the studied treatments on the color index of a* in A. bisporus mushroom was significant at a 5% probability level of Duncan’s test. Moreover, the maximum value of the color index of a* was observed in the canning treatment with a value of 12.93, while the minimum value was seen in the infrared, hot air, and control group treatments with values of -0.86, 0.26, and 0.76, respectively; no statistically significant difference was observed at the 5% probability level of Duncan's test (Figure 6).
Figure 6. Comparison between the means- the effect of different treatments on the color index of a* in A. bisporus mushrooms. Means with at least one letter in common do not have significant difference at 5% probability level of Duncan's test.
Color index of b*
Data analysis of variance revealed a significant difference in the impact of the treatment on the color index of b* in A. bisporus mushrooms at a 1% probability level (Table 2). The results of comparing the means also showed that the impact of the studied treatments on the color index of b* was significant at a 5% probability level of Duncan’s test. According to the results, the maximum value of the color index of b* was observed in the salting and canning treatments with values of 33.93 and 31.03, respectively. The minimum value was also detected in the control group, infrared, and hot air treatments with the values of 16.03, 18.02, and 20.86, respectively, and there was no statistically significant difference in some of the treatments at a 5% probability level of Duncan’s test (Figure 7).
Figure 7. Comparison between the means- the effect of different treatments on the color index of b* in A. bisporus mushrooms. Means with at least one letter in common do not have a significant difference at 5% probability level of Duncan's test.
Discussion and Conclusion
The effect of different processing treatments on some of the quality characteristics of A. bisporus mushroom
Shrinkage Ratio
The research findings revealed that the highest shrinkage ratio occurred during infrared treatment, while the lowest shrinkage ratio was observed in salting treatment. The structural heterogeneity of fruits and vegetables poses a challenge in understanding the chemical-physical changes that occur during drying. Food is one of the most complex deformable materials due to its heterogeneous structure. The porous and hygroscopic nature of fruits and vegetables leads to increased shrinkage during the drying process, which is the common physical process observed in the drying process (Kumar et al., 2018). Shrinkage significantly impacts the mechanical and textural properties of fruits and vegetables. Above all, shrinkage is a significant factor that has a remarkable impact on the rate and kinetics of dryness. Therefore, food researchers emphasize the importance of considering shrinkage in predicting mass and heat transfer during the drying process (Aprajeeta et al., 2015).
The shrinkage of foods depends on various factors, including material properties, mechanical characteristics, and the drying process itself. Understanding porosity can aid in accurately predicting transfer phenomena and quality attributes during dryness (Karunasena et al., 2014). Cell destruction and texture shrinkage occur during the drying process. There is an accurate distinction between shrinkage and destruction. Shrinkage refers to the mass reduction of the product while destruction means the irreversible decomposition of cellular and textural structure. Structural changes at the cellular level during drying are driven by transfer phenomena. As previously mentioned, porosity and shrinkage during the dryness affect the transfer process and other quality characteristics (Gulati et al., 2015).
In the initial drying stage, mass shrinkage is primarily due to the loss of water content. However, shrinkage also occurs in subsequent drying stages, resulting from the pressure inside the cells (Mahiuddin et al., 2018). Decreased turgor pressure results from transferring a significant amount of water out of the cells in the final phase of drying. The resulting tension is due to the moisture gradient during drying, while thermal tension is more pronounced in the beginning stages (Llave et al., 2016). In other words, when drying begins, the temperature gradient within the sample is significant, leading to thermal tension. As drying progresses, the temperature gradient decreases, having no effect on the shrinkage of content. Ultimately, the entire sample reaches a stable temperature close to that of the drier (Joardder et al., 2015) where the heat transfers to the surface moisture to evaporate. Therefore, the tension caused by moisture gradient is one of the leading causes of shrinkage during drying (Mercier et al., 2011).
The highest shrinkage ratio in the texture of A. bisporus mushroom was observed with the infrared treatment, likely due to the low moisture content in this treatment, creating the hard porous shell. As a result, the moisture of the surface decreases rapidly, generating internal pressures within the texture, negatively impacting the shrinkage and creating significant porosity in the internal structure. Affected by other processing treatments, such as salting, the drying process of the product typically initiates at the outer layer, causing surface dryness and low porosity while preventing moisture extraction by forming a hard outer layer on the food. This effect is intensified by the high amount of sugar in agricultural products, further increasing the surface hardening. These findings are consistent with the results of research on the drying of lime (Kaveh et al., 2019) and garlic slices (Tao et al., 2018).
Research results showed that the highest amount of fat was found in hot air treatment, while the lowest amount was observed in canning and salting treatments. There was a strong correlation between the fat content and the quality of the final processed product, and numerous studies were conducted on fat changes during the thermal process and canning. In the current research, the fat percentage in the A. bisporus mushroom dried with canning and salting treatments was significantly lower compared to drying through hot air, likely due to the retention of total organic matter ratios in each treatment (Yang et al., 2020). This means that as the protein percentage increased in canning and salting treatment, the percentage of other organic matter, including fat, decreased in the same ratio. While fat is a nutritional organic matter, it is one of the most influential factors in the lifespan of the product, which is due to fat oxidation during long-term storage (Li et al., 2015). It is apparent that the higher the fat percentage, the higher the possibility of oxidation, prompting efforts to reduce fat content during production. In this study, the highest percentage was found in A. bisporus samples dried with hot air treatment. The elevated temperatures, due to the increase in protein denaturation and an increase in nonpolar amino acids in the side chain of the protein structure, led to more fat absorption by proteins, resulting in increased fat content in the sample (Yang et al., 2020).
Color indices
The research results indicated that the highest Browning index, color change, and color index of a* were observed in the canning treatment, while the lowest values were seen in infrared and hot air treatments. The highest color index of L* was found in the control group, infrared, and hot air treatments, with the lowest value in canning treatment. Maximum color index of b* was seen in salting and canning treatments, while the minimum was observed in the control group, infrared, and hot air treatments.
Undesirable color is a result of Browning reactions. Factors such as moisture, temperature, pH, and food compounds accelerate the Browning reactions and Maillard's non-enzymatic browning. Rapid browning typically occurs in the middle range of moisture content, decreasing with higher or lower moisture levels. Canning treatment was found to increase the Browning index of A. bisporus mushrooms (Chuensun et al., 2020).
When stress occurs within the tissue of the product, cells may face obstacles in their movement path, leading to the combination of phenolic compounds, such as catechin and polyphenols, with polyphenol oxidase or phenol peroxidase. This process can be more pronounced in some areas, being darker than in other areas (Cavusoglu et al., 2021). Additionally, air bubbles in the product tissue can cause the transfer of the phenolic compounds to the vacuole or the cellular wall. Small amounts of phenolic compounds may also be present in the chromoplast, cytoplasm, and mitochondrion, contributing to uneven color patterns during enzymatic Browning (Huang et al., 2019).
Hot air and infrared treatments reduce the drying time by causing consecutive shrinkage and expansion, creating longer microscopic channels. This results in A. bisporus mushroom samples being exposed to high temperatures for a shorter period of time, preventing further degradation of pigments in the mushroom samples. Infrared radiation helps maintain the color properties in medicinal products like A. bisporus mushrooms by decreasing the drying time and limiting the time of enzymatic reactions of browning. Additionally, the optimal air flow positively impacts the color quality of product by reducing drying time (Ebadi et al., 2016). Kocabiyik et al. (2015) and Kantrong et al. (2014) reported similar results.
Color index b* indicates the range of changes from blue to yellow, and its increasing trend with salting and canning treatments shows the increase in yellowness over time (Shafeei et al., 2014). This increase in the yellowness can be attributed to reactions resulting in Browning. In mushroom samples processed by salting and canning treatments, the levels of redness and yellowness (a* and b*) increase due to reduced moisture content, explaining the non-enzymatic browning of samples. This process is more effective in low moisture conditions, which is why dry food is more susceptible to Browning. The changes in redness and brightness parameters are linked to enzymatic reactions of browning, where an increase in the Browning index leads to decreased brightness and increased redness (Duan et al., 2022). The research findings align with studies conducted by Duan et al. (2022) and Cavusoglu et al. (2021) on Button mushrooms.
Conclusion
In general, the research findings revealed that infrared and hot air treatments significantly impacted the improvement of color indices, such as Browning index, color change, and color index of a* and b*. Moreover, canning treatment reduced the color index of L* in A. bisporus mushroom samples. Salting treatment also decreased the shrinkage ratio. Therefore, producers and experts in medicinal-edible mushroom cultivation are recommended to employ these treatments to process and increase the product storage time to maintain the quality characteristics of the mushroom.
References
Adak N, Heybeli N, Ertekin C. 2017. Infrared drying of strawberry. Food Chemistry, 219: 109-116.
Aliaño-González MJ, Barea-Sepúlveda M, Espada-Bellido E, Ferreiro-González M, López-Castillo JG, Palma M, Barbero GF, Carrera C. 2022. Ultrasound-assisted extraction of total phenolic compounds and antioxidant activity in mushrooms. Agronomy, 12: 1812.
Aniesrani Delfiya DS, Prashob K, Mural S, Alfiya PV, Samuel MP, Pandiselvam R. 2021. Drying kinetics of food materials in infrared radiation drying: A review. Journal of Food Process Engineering, 2021: e13810, pp: 1-19.
Aprajeeta J, Gopirajah R, Anandharamakrishnan C. 2015. Shrinkage and porosity effects on heat and mass transfer during potato drying. Journal of Food Engineering, 144: 119–128.
Benoutman A, Erbiai EH, Edderdaki FZ, Cherif EK, Saidi R, Lamrani Z, Pintado M, Pinto E, Esteves da Silva JCG, Maouni A. 2022. Phytochemical composition, antioxidant and antifungal activity of Thymus Capitatus, a medicinal plant collected from Northern Morocco. Antibiotics, 11: 681.
Bhatta S, Janezic TS, Ratti C. 2020. Freeze-drying of plant-based foods. Foods, 9: 87.
Biernacka B, Dziki D, Rudy S, Krzykowski A, Polak R, Dziki L. 2022. Influence of pretreatments and freeze-drying conditions of strawberries on drying kinetics and physicochemical properties. Processes, 10: 1588.
Bostani S, Asefi N. 2021. The effect of drying process on the physiochemical characteristics and quality of Basil leaf leaves. Journal of Food Technology and Nutrition, pp. 5- 16.
Cavusoglu S, Uzun Y, Yilmaz N, Ercisli S, Eren E, Ekiert H, Elansary HO, Szopa A. 2021. Maintaining the quality and storage life of button mushrooms (Agaricus bisporus) with gum, agar, sodium alginate, egg white protein, and lecithin coating. Journal of Fungi, 7: 614.
Cavusoglu S, Uzun Y, Yilmaz N, Ercisli S, Eren E, Ekiert H, Elansary HO, Szopa A. 2021. Maintaining the quality and storage life of button mushrooms (Agaricus bisporus) with gum, agar, sodium alginate, egg white protein, and lecithin coating. Journal of Fungi, 7: 614.
Chao J, Dai Y, Cheng HY, Lam W, Cheng YC, Li K, Peng WH, Pao LH, Hsieh MT, Qin XM. 2017. Improving the concentrations of the active components in the herbal tea ingredient, uraria crinita: The effect of post-harvest oven-drying processing. Scientific Reports, 7: 38763.
Chen Y, Cai W, Shi Y, Dong X, Bai F, Shen S, Jiao R, Zhang X, Zhu X. 2020. Effects of different salt concentrations and vacuum packaging on the shelf-stability of Russian sturgeon (Acipenser gueldenstaedti) stored at 4 °C. Food Control, 109: 106865
Chuensun T, Chewonarin T, Laopajon W, Kawee-ai A, Pinpart P, Utama-ang N. 2020. Comparative evaluation of physicochemical properties of Lingzhi (Ganoderma lucidum) as affected by drying conditions and extraction methods. Food Traceability and Security, 56: 2751-2759.
Coşkun S, Doymaz İ, Tunçkal C, Erdoğan S. 2017. Investigation of drying kinetics of tomato slices dried by using a closed loop heat pump dryer. Heat Mass Transfer, 53: 1863-1871.
Da Silva AC, Jorge N. 2014. Influence of Lentinus edodes and Agaricus blazei extracts on the prevention of oxidation and retention of tocopherols in soybean oil in an accelerated storage test. Journal of Food Science and Technology, 51: 1208-12.
Dawadi E, Magar PB, Bhandari S, Subedi S, Shrestha S, Shrestha J. 2022. Nutritional and post-harvest quality preservation of mushrooms: A review. Heliyon, 12: e12093.
De Araujo MEV, Barbosa EG, Lopes RP, Corrêa PC, Barbosa EG. 2021. Infrared drying of pear slices: drying kinetics, energy, and exergy analysis. Journal of Food Process Engineering, 44: e13915.
Duan X, Miao J, Huang L, Li B. 2022. Microwave freeze-drying of button mushroom (Agaricus bisporus) based on nonvolatile taste components by controlling microwave power density. International Journal of Food Science and Technology, 57: 379-389.
Duan X, Miao J, Huang L, Li B. 2022. Microwave freeze-drying of button mushroom (Agaricus bisporus) based on nonvolatile taste components by controlling microwave power density. International Journal of Food Science and Technology, 57: 379-389.
Ebadi MT, Sefidkon F, Azizi M, Ahmadi N. 2016. Effects of air velocity and infrared radiation intensity on drying factors of lemon verbena (Lippia citriodora Kunth.). Iranian Journal of Medicinal and Aromatic Plants Research, 32: 161-173.
Elmastas M, Isildak O, Turkekul I, Temur N. 2007. Determination of antioxidant activity and antioxidant compounds in wild edible mushrooms. Journal of Food Composition and Analysis, 20: 337–345.
Erbiai EH, Maouni A, Pinto da Silva L, Saidi R, Legssyer M, Lamrani Z, Esteves da Silva JCG. 2023. Antioxidant properties, bioactive compounds contents, and chemical characterization of two wild edible mushroom species from Morocco: Paralepista flaccida (Sowerby) Vizzini and Lepista nuda (Bull.) cooke. Molecules, 28: 1123.
Esmaeili Y, Zamindar N, Mohammadi R. 2023. The effect of polypropylene film containing nano-hydroxyapatite on Physicochemical and microbiological properties of button mushrooms (Agaricus bisporus) under Modified atmosphere packaging. Journal of Food Measurement, 17: 773–786.
Farias Menezes TM, Campelo MS, Nogueira Lima AB, Câmara Neto JF, Morais Saraiva M, Costa de Sousa JA, Costa Gonzaga ML, Moreira Leal LKA, Pinho Ribeiro MEN, Silva Ricardo NMP, Aguiar Soares S. 2022. Effects of polysaccharides isolated from mushrooms (Lentinus edodes Berk or Agaricus blazei Murill) on the gelation of Pluronic® F127. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 642: 128684.
Feng Y, Tan CP, Zhou C, Yagoub AEA, Xu B, Sun Y. 2020. Effect of freeze-thaw cycles pretreatment on the vacuum freeze-drying process and physicochemical properties of the dried garlic slices. Food Chemistry, 324: 10.1016/j.foodchem.2020.126883
Gao R, Yu Q, Shen Y, Chu Q, Chen G, Fen S, Yang M, Yuan L, McClements DJ. Sun Q. 2021. Production, bioactive properties and potential application of fish protein hydrolysates: Developments and challenges. Trends in Food Science and Technology, 110: 687-699.
Geng Z, Wang H, Torki M, Beigi M, Zhu L, Huang X, Yang X, Hu B. 2023. Thermodynamically analysis and optimization of potato drying in a combined infrared/convective dryer. Case Studies in Thermal Engineering, 42: 102671.
Golpour I, Kaveh M, Blanco-Marigorta AM, Marcos JD, Guiné RPF, Amiri Chayjan R, Khalife E, Karami H. 2022. Multi-Response design optimisation of a combined fluidised bed-infrared dryer for terebinth (Pistacia atlantica L.) fruit drying process based on energy and exergy assessment by applying RSM-CCD modelling. Sustainability, 14: 15220.
Gulati T, Datta AK. 2015. Mechanistic understanding of case-hardening and texture development during drying of food materials. Journal of Food Engineering, 166: 119–138.
Guo Y, Chen X, Gong P, Wang R, Qi Z, Deng Z, Han A, Long H, Wang J, Yao W. 2023. Advances in post-harvest storage and preservation strategies for Pleurotus eryngii. Foods, 12: 1046.
Hu L, Bi J, Jin X, Qiu Y, Sman RGM. 2021. Study on the rehydration quality improvement of Shiitake mushroom by combined drying methods. Foods, 10: 769.
Huang K, El-Seedi HR, Xu B. 2022. Critical review on chemical compositions and health-promoting effects of mushroom Agaricus blazei Murill. Current Research in Food Science, 5: 2190–2203.
Huang Q, Qian X, Jiang T, Zheng X. 2019. Effect of chitosan and guar gum based composite edible coating on quality of mushroom (Lentinus edodes) during post-harvest storage. Scientia Horticulturae, 253: 382–389.
Inyang UE, Oboh IO, Etuk BR. 2018. Kinetic Models for Drying Techniques—Food Materials. Advances in Chemical Engineering and Science, 8: 27–48
Iranshahi K, Rubinetti D, Onwude DI, Psarianos M, Schlüter OK, Defraeye Th. 2023. Electrohydrodynamic drying versus conventional drying methods: A comparison of key performance indicators. Energy Conversion and Management, 279: 116661.
Jan I, Rab A, Sajid M, Ali A, Shah S. 2012. Response of apple cultivars to different downloaded from storage durations. Sarhad Journal of Agriculture, 28: 219-225.
Jaworska G, Bernas E, Mickowska B. 2011. Effect of production process on the amino acid content of frozen and canned Pleurotus ostreatus mushrooms. Food Chemistry, 125: 936–943.
Jiang L, Yu Z, Lin Y, Cui L, Yao S, Lv L, Liu J. 2018. Low-molecular-weight polysaccharides from Agaricus blazei Murrill modulate the Th1 response in cancer immunity. Oncology Letters, 15: 3429–3436.
Jiang T. 2013. Effect of alginate coating on physicochemical and sensory qualities of button mushrooms (Agaricus bisporus) under a high oxygen modified atmosphere. Post-harvest Biology and Technology, 76: 91-97.
Joardder MUH, Brown RJ, Kumar C, Karim MA. 2015. Effect of cell wall properties on porosity and shrinkage of dried apple. Journal of Food Properties, 18: 2327–2337.
Joardder MUH, Kumar C, Karim MA. 2018. Prediction of porosity of food materials during drying: Current challenges and directions. Critical Reviews in Food Science and Nutrition, 58: 2896–2907.
Kannan A, Neeharika K. 2014. Estimation of energy consumption in thermal sterilization of canned liquid foods in still retorts. Engineering Applications of Computational Fluid Mechanics, 4: 288–303.
Kantrong H, Tansakul A, Mittal GS. 2014. Drying characteristics and quality of shiitake mushroom undergoing microwave-vacuum drying and microwave-vacuum combined with infrared drying. Journal of Food Science and Technology, 51: 3594-3608.
Karunasena HCP, Senadeera W, Brown RJ, Gu YTA. 2014. Particle based model to simulate microscale morphological changes of plant tissues during drying. Soft Matter, 10: 5249– 5268.
Kaveh M, Jahanbakhshi A, Askari AsliArdeh E, Imanian K. 2019. Sour lemon drying by hot air drying under ultrasonic pretreatmen. Journal of Research and Innovation in Food Science and Technology, 6: 233-245.
Kıan-pour N. 2020. Fundamental drying techniques applied in food science and technology. International Journal of Food Engineering Research, 6: 35–63
Kocabiyik H, Yilmaz N, Tuncel NB, Sumer SK, Buyukcan MB. 2015. Drying, energy, and some physical and nutritional quality properties of tomatoes dried with short-infrared radiation. Food and Bioprocess Technology, 8: 516-525.
Kothari D, Patel S, Kim SK. 2018. Anticancer and other therapeutic relevance of mushroom polysaccharides: A holistic appraisal. Biomedicine and Pharmacotherapy, 105: 377–394.
Kręcisz M, Kolniak-Ostek J, Łyczko J, Stępień B. 2023. Evaluation of bioactive compounds, volatile compounds, drying process kinetics and selected physical properties of vacuum impregnation celery dried by different methods. Food Chemistry, 413: 135490.
Krzykowski A, Dziki D, Rudy S, Polak R, Biernacka B, Gawlik-Dziki U, Janiszewska-Turak E. 2023. Effect of air-drying and freeze-drying temperature on the process kinetics and physicochemical characteristics of white mulberry fruits (Morus alba L.). Processes, 11: 750.
Kumar C, Joardder MUH, Farrell TW, Karim MA. 2018. Investigation of intermittent microwave convective drying (IMCD) of food materials by a coupled 3d electromagnetics and multiphase model. Drying Technology, 36: 736–750.
Li W, Li R, Chen W, Feng J, Wu D, Zhang Z, Zhang J, Yang Y. 2022. The anabolism of sulphur aroma volatiles responds to enzymatic and non-enzymatic reactions during the drying process of shiitake mushrooms. Food Chemistry, 371: 131123.
Lin Q, Lu Y, Zhang J, Liu W, Guan W, Wang Z. 2017. Effects of high CO2 in-package treatment on flavor, quality and antioxidant activity of button mushroom (Agaricus bisporus) during post-harvest storage. Post-harvest Biology and Technology, 123: 112–118.
Liu C, Sheng J, Chen L, Zheng Y, Lee DYW, Yang Y, Xu M, Shen L. 2015. Biocontrol activity of Bacillus subtilis isolated from Agaricus bisporus mushroom compost against pathogenic fungi. Journal of Agricultural and Food Chemistry, 63: 6009–6018.
Liu J, Jia L, Kan J, Jin C. 2013. In vitro and in vivo antioxidant activity of ethanolic extract of white button mushroom (Agaricus bisporus). Food and Chemical Toxicology, 51: 310–316.
Llave Y, Takemori K, Fukuoka M, Takemori T, Tomita H, Sakai N. 2016. Mathematical modeling of shrinkage deformation in eggplant undergoing simultaneous heat and mass transfer during convection-oven roasting. Journal of Food Engineering, 178: 124–136.
Mahiuddin M, Khan MIH, Kumar C, Rahman MM, Karim MA. 2018. Shrinkage of food materials during drying: current status and challenges. Comprehensive Reviews in Food Science and Food Safety, 17: 1113–1126.
Marçal S, Sousa AS, Taofiq O, Antunes F, Morais AM, Freitas AC, Barros L, Ferreira IC, Pintado M. 2021. Impact of post-harvest preservation methods on nutritional value and bioactive properties of mushrooms. Trends in Food Science & Technology, 110: 418–431.
Martin-Belloso O, Lianos-Barriobero E. 2001. Proximate composition, minerals and vitamins in selected canned vegetables. European Food Research and Technology, 212: 182–187.
Martysiak-Zurowska D, Rozek P, Puta M. 2020. The effect of freeze-drying and storage on lysozyme activity, lactoferrin content, superoxide dismutase activity, total antioxidant capacity and fatty acid profile of freeze-dried human milk. Drying Technology, 2020: 1–11
Mercier S, Villeneuve S, Mondor M, Des Marchais LP. 2011. Evolution of porosity, shrinkage and density of pasta fortified with pea protein concentrate during drying. LWT - Food Science and Technology, 44: 883–890.
Mierzwa D, Pawłowski A. 2017. Convective drying of potatoes assisted by microwave and infrared radiation–process kinetics and quality aspects. Journal of Food and Nutrition Research, 56: 351-361.
Mirzaei S, Ameri M, Ziaforoughi A. 2021. Energy-exergy analysis of an infrared dryer equipped with a photovoltaicthermal collector in glazed and unglazed modes. Renewable Energy, 169: 541-556.
Misgiati M, Sukardiman S, Widyawaruyanti A. 2017. Anti-breast cancer potency of multistage extraction from jamur dewa (Agaricus blazei Murill) solvents on MCF-7 cells. Indonesian Journal of Cancer Chemoprevention, 8: 68-73.
Monirujamman M. 2014. Metabolic and physiological roles of branched chain amino acids. Advances in Molecular Biology, 2014: 364976
Motevali A, Jafari H, Hashemi JS. 2018. Effect of IR intensity and air temperature on exergy and energy at hybrid infrared-hot air dryer. Chemical Industry & Chemical Engineering Quarterly, 24: 31-42.
Nketia S, Buckman ES, Dzomeku M, Akonor PT. 2020. Effect of processing and storage on physical and texture qualities of oyster mushrooms canned in different media. Scientific African, 9: e00501.
Parmar N, Singh N, Kaur A, Virdi AS, Thakur S. 2016. Effect of canning on color, protein and phenolic profile of grains from kidney bean, field pea and chickpea. Food Research International, 89: 526-532.
Parmar N, Singh N, Kaur A, Virdi AS, Thakur S. 2016. Effect of canning on color, protein and phenolic profile of grains from kidney bean, field pea and chickpea. Food Research International, 89: 526-532.
Pogoń K, Gabor A, Jaworska G, Bernaś E. 2017. Effect of traditional canning in acetic brine on the antioxidants and vitamins in boletus edulis and suillus luteus mushrooms. Journal of Food Processing and Preservation, 41: doi:10.1111/jfpp.12826.
Praneetpolkrang P, Sathapornprasath K. 2021. Thin-layer drying model of jackfruit using artificial neural network in a far infrared dryer. Engineering and Applied Science Research, 48: 181–189.
Pursito DJ, Purnomo EH, Fardiaz D, Hariyadi P. 2022. Effect of sterility values and retort temperatures on the antioxidant activities, soluble protein, and pH of canned mushroom. Current Research in Nutrition and Food Science, 10: 553-565.
Qin L, Gao JX, Xue J, Chen D, Lin SY, Dong XP, Zhu BW. 2020. Changes in aroma profile of shiitake mushroom (Lentinus edodes) during different stages of hot air drying. Foods, 9: 444, doi:10.3390/foods9040444.
Reis FR, Marques C. de Moraes ACS, Masson ML. 2022. Trends in quality assessment and drying methods used for fruits and vegetables. Food Control, 142: 109254
Rekik C, Besombes C, Hajji W, Gliguem H, Bellagha S, Mujumdar AS, Karim Allaf K. 2021. Study of interval infrared airflow drying: A case study of butternut (Cucurbita moschata). LWT - Food Science and Technology, 147: 111486.
Reshmi NP, Mandal G, Thokchom R. 2018. Effect of pre-treatment of salt solution and drying methods on the quality of processed aonla (Emblica officinalis Gaertn.). International Journal of Current Microbiology and Applied Sciences, 7: 1438-1446.
Salehi F. 2020. Recent applications and potential of infrared dryer systems for drying various agricultural products: A review. International Journal of Fruit Science, 20: 586-602.
Santi-Rampazzo AP, Schoffen JP, Cirilo CP, Zapater MC, Vicentini FA, Soares AA. 2015. Aqueous extract of Agaricus blazei Murrill prevents age-related changes in the myenteric plexus of the jejunum in rats. Evidence-Based Complementary and Alternative Medicine, 2015: 01-13.
Savas E. 2022. The modelling of convective drying variables’ effects on the functional properties of sliced sweet potatoes. Foods, 11: 741.
Sério S, Rivero -Pèrez MD, Correia AC, Jordao AM, Gonzàlez -San Josè ML. 2014. Analysis of commercial grape raisins: Phenolic content, antioxidant capacity and radical scavenger activity. Ciência e Técnica Vitivinícola, 29: 1 -8.
Song F, Li Z, Raghavan GSV. 2017. Combined microwave–hot-air drying of burdock slices with feedback temperature control at surface and core. Drying Technology, 35: 1781-1790.
Stevanato N, Ribeiro TH, Giombelli C. 2020. Effect of canning on the antioxidant activity, fiber content, and mechanical properties of different parts of peach palm heart. Journal of Food Processing and Preservation, 44: e14554.
Sun M, Ni L, Huang Y, Yang M, Cheng G, Zhang M, Wu M, Ma C. 2023. Effects of different drying treatments on the microstructure, free amino acids, volatile compounds and antioxidant activity of Flammulina velutipes root. Food Chemistry, 18: 100656.
Szadzińska J, Mierzwa D, Musielak G. 2022. Ultrasound-assisted convective drying of white mushrooms (Agaricus bisporus). Chemical Engineering and Processing - Process Intensification, 172: 108803.
Tang Y, Chen G, Wang D, Hu R, Li H, Liu S, Zhang Q, Ming J, Chi Y. 2022. 2022. Effects of dry-salting and brine-pickling processes on the physicochemical properties, nonvolatile flavour profiles and bacterial community during the fermentation of Chinese salted radishes. LWT - Food Science and Technology, 157: 113084.
Tao Y, Zhang J, Jiang S, Xu Y, Show PL, Han Y, Ye X, Ye M. 2018. Contacting ultrasound enhanced hot-air convective drying of garlic slices: Mass transfer modeling and quality evaluation. Journal of Food Engineering, 235: 79-88.
Tetteh ONA, Ulrichs C, Huyskens-Keil S, Mewis I, Amaglo NK, Oduro IN, Adarkwah C, Obeng-Ofori D, Förster N. 2019. Effects of harvest techniques and drying methods on the stability of glucosinolates in Moringa oleifera leaves during post-harvest. Scientia Horticulturae, 246: 998–1004.
Tian Y, Zhao Y, Huang J, Zeng H, Zheng B. 2016. Effects of different drying methods on the product quality and volatile compounds of whole shiitake mushrooms. Food Chemistry, 197: 714-722.
Timm NS, Lang GH, Ferreira CD, Pohndorf RS, Oliveira M. 2020. Infrared radiation drying of parboiled rice: Influence of temperature and grain bed depth in quality aspects. Journal of Food Process Engineering, 43: e13375. https://doi.org/10.1111/jfpe.13375.
Torki-Harchegani M, Ghasemi-Varnamkhasti M, Ghanbarian D, Sadeghi M, Tohidi M. 2016. Dehydration characteristics and mathematical modelling of lemon slices drying undergoing oven treatment. Heat and Mass Transfer, 52: 281-289.
Victor WC, Obele S. 2013. The effect of brine solution on mushroom (Pleurotus ostreatus) preserved at room temperature (26- 300C). Greener Journal of Agricultural Sciences, 3: 445-447.
Wang H, Zhang M, Adhikari B. 2015. Drying of shiitake mushroom by combining freeze-drying and mid-infrared radiation. Food and Bioproducts Processing, 94: 507-517.
Wang H, Zhang M, Mujumdar AS. 2014. Comparison of three new drying methods for drying characteristics and quality of Shiitake mushroom (Lentinus edodes). Drying Technology: An International Journal, 32: 1791-1802.
Wang J, Wu J, Ogura R, Kobori H, Choi JH, Hirai H, Takikawa Y, Kawagishi H. 2022. Anti-phytopathogenic-bacterial fatty acids from the mycelia of the edible mushroom Agaricus blazei. Bioscience Biotechnology and Biochemistry, zbac117, https://doi.org/10.1093/bbb/zbac117.
Wang Y, Li T, Pan Z, Ye X, Ma H. 2023. Effectiveness of combined catalytic infrared radiation and holding time for decontamination Aspergillus niger on dried shiitake mushrooms (Lentinus edodes) with different moisture contents. LWT - Food Science and Technology, 176: 114503.
Wen YX, Chen LY, Li BS, Ruan Z, Pan Q. 2021. Effect of infrared radiation-hot air (IR-HA) drying on kinetics and quality changes of star anise (Illicium verum). Drying Technology, 39: 90–103.
Wongsa P, Bhuyar P, Tongkoom K. 2023. Influence of hot-air drying methods on the phenolic compounds/allicin content, antioxidant activity and α-amylase/α-glucosidase inhibition of garlic (Allium sativum L.). European Food Research and Technology, 249: 523–535.
Workneh TS, Zinash A, Woldetsadik K. 2014. Blanching, salting and sun drying of different pumpkin fruit slices. Journal of Food Science and Technology, 51: 3114–3123.
Wu X, Zhang M, Bhandari B. 2019. A novel infrared freeze drying (IRFD) technology to lower the energy consumption and keep the quality of Cordyceps militaris. Innovative Food Science & Emerging Technologies, 54: 34-42.
Xi J, Chen X, Du J, Zhong L, Hu Q, Zhao L. 2023. Biosynthesis, behavior and fate of volatile organic sulfide in Lentinus edodes (Berk.) upon hot-air drying treatment. Food Chemistry, 412: 135528.
Xu L, Fang X, Wu W, Chen H, Mu H, Gao H. 2019. Effects of high-temperature pre-drying on the quality of air-dried shiitake mushrooms (Lentinula edodes). Food Chemistry, 285: 406-413.
Xue Z, Hao J, Yu W, Kou X. 2016. Effects of processing and storage preservation technologies on nutritional quality and biological activities of edible fungi: a review. Journal of Food Process Engineering, pp: 1-13.
Yang LH, Liu LD, Wang XJ, Qu HG, Ma QH, Cai DH. 2007. Effects of salting on extraction of Agaricus bisporus polysaccharides. Food Science, 10: 151–154.
Yang RL, Li Q, Hu QP. 2020. Physicochemical properties, microstructures, nutritional components, and free amino acids of Pleurotus eryngii as afected by diferent drying methods. Scientific Reports, 10:121
Yang XH, Deng LZ, Mujumdar AS, Xiao HW, Zhang Q, Kan Z. 2018. Evolution and modeling of colour changes of red pepper (Capsicum annuum L.) during hot air drying. Journal of Food Engineering, 231: 101-108.
Zadhossein S, Abbaspour-Gilandeh Y, Kaveh M, Nadimi M, Paliwal J. 2023. Comparison of the energy and exergy parameters in cantaloupe (Cucurbita maxima) drying using hot air. Smart Agricultural Technology, 4: 100198.
Zhang L, Dong X, Feng X, Ibrahim SA, Huang W, Liu Y. 2021. Effects of drying process on the volatile and nonvolatile flavor compounds of Lentinula edodes. Foods, 10: 2836.
Zhao X, Wei Y, Gong X, Xu H, Xin G. 2020. Evaluation of umami taste components of mushroom (Suillus granulatus) of different grades prepared by different drying methods. Food Science and Human Wellness, 9: 192-198.
Zou XG, Chi Y, Cao YQ, Zheng M, Deng ZY, Cai M, Yang K, Sun PL. 2023. Preparation process optimization of peptides from Agaricus blazei Murrill, and comparison of their antioxidant and immune-enhancing activities separated by ultrafiltration membrane technology. Foods, 12: 251.
