Laboratory investigation of using a ternary polymer of itaconic acid-sodium polystyrene sulfonate-acrylamide as an inhibitor for calcium carbonate scaling in formation water

Subject Areas : journal of New Materials

Adolreza Dabiri ¹ (Department of Petroleum Engineering, Marvdasht Branch, Islamic Azad University, Marvdasht, Iran)
Mohammad Afkhami Karaei ² (Department of Petroleum Engineering, Firoozabad Branch, Islamic Azad University, Firoozabad,Iran)

Received: 2023-12-31 Accepted : 2024-01-24 Published : 2023-04-21

Keywords: Formation water flooding, calcium carbonate deposition, inhibition performance coefficient, calcite crystal,

Abstract :

Abstract
Introduction: Water flooding is one of the methods of enhanced oil recovery in which formation water is injected into the oil reservoir. Calcium carbonate deposition is one of the challenges in the field of water flooding and oil production. It leads to a reduction in oil production due to deposition on reservoir rocks and the path of oil movement.
Methods: The use of chemical additives, especially hydrophilic polymers, has been widely studied to prevent calcium carbonate deposition. In this study, a ternary hydrophilic polymer was used to investigate the inhibitory effect on calcium carbonate scale in the formation water of an Iranian oil reservoir. The optimal concentration of this polymer, considering its inhibitory performance coefficient in formation water, was determined to be 800 milligrams per liter based on the calcium ion concentration. This optimal concentration was then used for subsequent experiments. Temperature studies on the inhibitory performance of this polymer showed that at reservoir temperature (75 degrees Celsius), 800 milligrams/lit of this ternary polymer demonstrated good performance. Scanning Electron Microscopy (SEM) and X-ray Diffraction (XRD) were used to study the physical mechanisms involved in preventing calcium carbonate deposition.
Findings: SEM results showed that calcium carbonate crystals, in the form of stable calcite with a regular uniform structure before the presence of the inhibitor, became heterogeneous and smaller in size after adding the polymer, disrupting their structure. On the other hand, XRD analysis indicated that adding this ternary polymer could significantly inhibit the growth of calcium carbonate crystals and prevent the transformation of vaterite into calcite. Additionally, aragonite crystals are dispersed in the water and washed away by the water flow.

References:

1. Li J, Zhou Y, Yao Q, Wang T, Zhang A, Chen Y, Wu W, Sun W. Preparation and evaluation of a polyether-based polycarboxylate as a kind of inhibitor for water systems. Industrial & Engineering Chemistry Research. 2017 Mar 15;56(10):2624-33. https://doi.org/10.1021/acs.iecr.6b04427


2. Liu X, Jungang L, Qianya Z, Jinlai F, Yingli L, Jingxin S. The analysis and prediction of scale accumulation for water-injection pipelines in the Daqing Oilfield. Journal of petroleum Science and Engineering. 2009 Jun 1;66(3-4):161-4. https://doi.org/10.1016/j.petrol.2009.02.007


3. Olajire AA. A review of oilfield scale management technology for oil and gas production. Journal of petroleum science and engineering. 2015 Nov 1;135:723-37. https://doi.org/10.1016/j.petrol.2015.09.011


4. Wang H, Zhou Y, Yao Q, Ma S, Wu W, Sun W. Synthesis of fluorescent-tagged scale inhibitor and evaluation of its calcium carbonate precipitation performance. Desalination. 2014 May 1;340:1-0. https://doi.org/10.1016/j.desal.2014.02.015


5. György Pátzay, F.H. Kármán, György Póta. Preliminary investigations of scaling and corrosion in high enthalpy geothermal wells in Hungary. Geothermics. 2003 Aug 1;32(4-6):627–38. https://doi.org/10.1016/S0375-6505(03)00068-3


6. Amiri M, Moghadasi J, Jamialahmadi M, Shahri MP. The Study of Calcium Sulfate Scale Formation during Water Injection in Iranian Oil Fields at Different Pressures. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects. 2013 Apr;35(7):648–58. https://doi.org/10.1080/15567036.2010.509092


7. Khan H, Malook K, Shah M. Synthesis, characterization, and electrical properties of polypyrrole–bimetallic oxide composites. Journal of Applied Polymer Science. 2019 Mar 22;137(2):47680. https://doi.org/10.1002/app.47680


8. Liu F, Lu X, Yang W, Lu J, Zhong H, Chang X, Zhao C. Optimizations of inhibitors compounding and applied conditions in simulated circulating cooling water system. Desalination. 2013 Mar 15;313:18-27. https://doi.org/10.1016/j.desal.2012.11.028


9. Senthilmurugan B, Ghosh B, Sanker S. High performance maleic acid based oil well scale inhibitors—Development and comparative evaluation. Journal of Industrial and Engineering Chemistry. 2011 May 25;17(3):415-20. https://doi.org/10.1016/j.jiec.2010.10.032


10. Khormali A, Petrakov DG. Laboratory investigation of a new scale inhibitor for preventing calcium carbonate precipitation in oil reservoirs and production equipment. Petroleum Science. 2016 May;13:320-7. https://doi.org/10.1007/s12182-016-0085-6


11. Chaussemier M, Pourmohtasham E, Gelus D, Pécoul N, Perrot H, Lédion J, Cheap-Charpentier H, Horner O. State of art of natural inhibitors of calcium carbonate scaling. A review article. Desalination. 2015 Jan 15;356:47-55. https://doi.org/10.1016/j.desal.2014.10.014


12. Rehman AU, Humayun M, Khan A, Zada A, Jing L. Effect of biocides on the precipitation of calcium fluoride in the presence of anionic copolymeric inhibitors. Toxicological & Environmental Chemistry. 2016 Aug 8;98(7):748-58. https://doi.org/10.1080/02772248.2015.1124107


13. Yang L, Yang W, Xu B, Yin X, Chen Y, Liu Y, Ji Y, Huan Y. Synthesis and scale inhibition performance of a novel environmental friendly and hydrophilic terpolymer inhibitor. Desalination. 2017 Aug 15;416:166-74. https://doi.org/10.1016/j.desal.2017.05.010


14. Liu Y, Zhou Y, Yao Q, Wang H, Wu Z, Chen Y, Liu L, Yang C, Wu W, Sun W. Preparation of a multifunctional terpolymer inhibitor for CaCO3 and BaSO4 in oil fields. Tenside Surfactants Detergents. 2016 Mar 16;53(2):148-56. https://doi.org/10.3139/113.110420


15. Cui C, Zhang S. Synthesis, characterization and performance evaluation of an environmentally benign scale inhibitor IA/AMPS co-polymer. New Journal of Chemistry. 2019;43(24):9472-82. DOI                https://doi.org/10.1039/C9NJ01355E


16. Yan J, Tan X, Qi S. High-Temperature-Resistant Scale Inhibitor Polyaspartic Acid-Prolineamide for Inhibiting CaCO3 Scale in Geothermal Water and Speculation of Scale Inhibition Mechanism. Water. 2023 Apr 8;15(8):1457–7. https://doi.org/10.3390/w15081457


17. Liu G, Wang H, Tang L, Xue M, Zhang C, Liu Q, et al. Scale Inhibition by a Carboxylate-Terminated Double-Hydrophilic Block Copolymer in Industrial Recycling Water. Journal of Water Chemistry and Technology. 2019 Mar 1;41(2):73–80. https://doi.org/10.3103/S1063455X19020024


18. Bu Y, Zhou Y, Yao Q, Chen Y, Sun W, Wu W. Inhibition of calcium carbonate and sulfate scales by a non-phosphorus terpolymer AA-APEY-AMPS. Desalination and Water Treatment. 2014 Nov 5;57(5):1977–87. https://doi.org/10.1080/19443994.2014.979443


19. Huang J, Liu G, Zhou Y, Yao Q, Yang Y, Ling L, et al. Acrylic acid–allylpolyethoxy carboxylate copolymer as an environmentally friendly calcium carbonate and iron(III) scale inhibitor. Clean Technologies and Environmental Policy. 2012 Oct 30;15(4):677–85. https://doi.org/10.1007/s10098-012-0540-z


20. Zhou M, Gu Y, Yi R, Han H. Synthesis and property study of ter-copolymer P(MA-AMPS-HPA) scale inhibitor. Journal of Polymer Research. 2020 Sep 4;27(10). https://doi.org/10.1007/s10965-020-02270-7


21. Kamali S, Reza Arefinia. Effect of PAAT as an Environmentally Friendly Terpolymer on the Scale Inhibition of CaCO3 in Artificial Seawater: Chemical and Electrochemical Study. Industrial & Engineering Chemistry Research. 2019 Dec 27;59(2):627–35. https://doi.org/10.1021/acs.iecr.9b05943


22. Chen Y, Zhou Y, Yao Q, Nan Q, Zhang M, Sun W. Performance on calcium scales inhibition in the presence of a novel double-hydrophilic block terpolymer. DESALINATION AND WATER TREATMENT. 2019 Jan 1;161:66–75.DOI: 10.5004/dwt.2019.24188


23. Ma W, Zhang Y, Li H. Synthesis and performance evaluation of carboxyl‐rich low phosphorus copolymer scale inhibitor. Journal of Applied Polymer Science. 2022 Nov 5;140(3). https://doi.org/10.1002/app.53333


24. Ma X, Zhou Z, Mu Y, Huang Q. Synthesis and evaluation of a new polymeric scale inhibitor with multiple scale inhibition properties. Journal of Dispersion Science and Technology. 2023 Feb 27;1–10. https://doi.org/10.1080/01932691.2023.2181182


25. Ma W, Yang L, Wu Y, Zhang Y, Liu C, Ma J, Sun B. Synthesis, characterization and properties of a novel environmentally friendly ternary hydrophilic copolymer. RSC advances. 2023;13(17):11685-96. https://doi.org/10.1039/D3RA00811H


26. Yang L, Yang W, Xu B, Yin X, Chen Y, Liu Y, Ji Y, Huan Y. Synthesis and scale inhibition performance of a novel environmental friendly and hydrophilic terpolymer inhibitor. Desalination. 2017 Aug 15;416:166-74. https://doi.org/10.1016/j.desal.2017.05.010


27. Shen Z, Li J, Xu K, Ding L, Ren H. The effect of synthesized hydrolyzed polymaleic anhydride (HPMA) on the crystal of calcium carbonate. Desalination. 2012 Jan 4;284:238-44. https://doi.org/10.1016/j.desal.2011.09.005


28. Du K, Zhou Y, Wang L, Wang Y. Fluorescent‐tagged no phosphate and nitrogen free calcium phosphate scale inhibitor for cooling water systems. Journal of applied polymer science. 2009 Aug 5;113(3):1966-74. https://doi.org/10.1002/app.30213


29. Senthilmurugan B, Ghosh B, Kundu SS, Haroun M, Kameshwari B. Maleic acid based scale inhibitors for calcium sulfate scale inhibition in high temperature application. journal of Petroleum Science and Engineering. 2010 Dec 1;75(1-2):189-95. https://doi.org/10.1016/j.petrol.2010.11.002


30. Amjad Z, Koutsoukos PG. Evaluation of maleic acid based polymers as scale inhibitors and dispersants for industrial water applications. Desalination. 2014 Feb 17;335(1):55-63. https://doi.org/10.1016/j.desal.2013.12.012


31. Khormali A, Petrakov DG, Moein MJ. Experimental analysis of calcium carbonate scale formation and inhibition in waterflooding of carbonate reservoirs. Journal of Petroleum Science and Engineering. 2016 Nov 1;147:843-50. https://doi.org/10.1016/j.petrol.2016.09.048


32. Liu Y, Zhou Y, Yao Q, Wang H, Wu Z, Chen Y, et al. Preparation of a Multifunctional Terpolymer Inhibitor for CaCO3 and BaSO4 in Oil Fields. Tenside Surfactants Detergents. 2016 Mar 16;53(2):148–56. https://doi.org/10.3139/113.110420


33. Zhang W, Li G, Jin F, Huo Y, Sun T, Li C. Synthesis and characterization of an ionic liquid–carboxylic acid copolymer scale inhibitor and its scale inhibition performance. Water Science & Technology: Water Supply. 2019 Jan 22;19(5):1463–72. https://doi.org/10.2166/ws.2019.011


34. Demadis KD, Katarachia SD. METAL-PHOSPHONATE CHEMISTRY: SYNTHESIS, CRYSTAL STRUCTURE OF CALCIUM-AMINOTRIS-(METHYLENE PHOSPHONATE) AND INHIBITION OF CACO3CRYSTAL GROWTH. Phosphorus, Sulfur, and Silicon and the Related Elements. 2004 Mar 1;179(3):627–48. https://doi.org/10.1080/10426500490441514


35. Wang H, Zhou Y, Yao Q, Ma S, Wu W, Sun W. Synthesis of fluorescent-tagged scale inhibitor and evaluation of its calcium carbonate precipitation performance. Desalination. 2014 May 1;340:1–10. https://doi.org/10.1016/j.desal.2014.02.015


36. Li H, Hsieh MK, Chien SH, Monnell JD, Dzombak DA, Vidic RD. Control of mineral scale deposition in cooling systems using secondary-treated municipal wastewater. Water research. 2011 Jan 1;45(2):748-60. https://doi.org/10.1016/j.watres.2010.08.052


37. Tang Y, Yang W, Yin X, Liu Y, Yin P, Wang J. Investigation of CaCO3 scale inhibition by PAA, ATMP and PAPEMP. Desalination. 2008 Aug 15;228(1-3):55-60. https://doi.org/10.1016/j.desal.2007.08.006


38. Liu Y, Zhou Y, Yao Q, Huang J, Liu G, Wang H, Cao K, Chen Y, Bu Y, Wu W, Sun W. Double‐hydrophilic polyether antiscalant used as a crystal growth modifier of calcium scales in cooling‐water systems. Journal of Applied Polymer Science. 2014 Jan 15;131(2). https://doi.org/10.1002/app.39792


39. Yang L, Yang W, Xu B, Yin X, Chen Y, Liu Y, Ji Y, Huan Y. Synthesis and scale inhibition performance of a novel environmental friendly and hydrophilic terpolymer inhibitor. Desalination. 2017 Aug 15;416:166-74. https://doi.org/10.1016/j.desal.2017.05.010


40. Dietzsch M, Barz M, Schüler T, Klassen S, Schreiber M, Susewind M, Loges N, Lang M, Hellmann N, Fritz M, Fischer K. PAA-PAMPS copolymers as an efficient tool to control CaCO3 scale formation. Langmuir. 2013 Mar 5;29(9):3080-8. https://doi.org/10.1021/la4000044.