Comparative assessment the magnetic properties of barium hexaferrite doped with paramagnetic and diamagnetic cations

Subject Areas :

sahebali manafi ¹ , مجتبی جعفریان ² , محسن صالحی ³

1 - هیات علمی
2 - محقق
3 - محقق

Received: 2015-12-18 Accepted : 2017-09-12 Published : 2017-08-23

Keywords: Barium hexaferrite, magnetization, Coercivity, paramagnetic, diamagnetic,

Abstract :

in this study, magnetic powders Ba (Mg, Ti)xFe12-2xO19 and Ba (Zn, Cu)xFe12-2xO19 with x=0.5 using mechanical alloying process a high-energy mill was prepared. Continuing a sample of pure powder and two samples doped powder was produced.In order to evaluate the phase, morphological and magnetic properties by X-ray diffraction analysis (XRD), field emission scanning electron microscope (FE-SEM) and vibrating sample magnetometer (VSM) was used. X-ray patterns in temperature 1000°C confirming the composition was almost single phase barium hexaferrite. SEM represents a hexagonal plate morphology due to preferential growth of particles in the ab crystallographic directions, respectively. Magnetic studies revealed the presence of diamagnetic ions of zinc and copper in the structure of barium hexaferrite more effective than paramagnetic cations magnesium and titanium saturation magnetization and the coercivity is reduced parameters. high saturation magnetization (53emu/g) of the sample produced composition and the lowest power BaMg0.5Ti0.5Fe11O19 coercivity (50Oe) of the samples were obtained by combining BaZn0.5Cu0.5Fe11O19

References:

 [1]      الف. نوربخش، م. نوربخش، م. شایگان و س. غربیان، "تأثیر افزودن یون کروم بر آنالیز فازی ریزساختاری وخواص مغناطیسی بدنه های هگزافریت استرانسیوم تهیه شده به روش حالت جامد"، فصلنامه علمی پژوهشی مهندسی مواد مجلسی، شماره 4، 4، زمستان 89.

 

[2]      ه. گلپایگانی، ع. بیت الهی و م. نیایی فر،"بررسی مقایسه ای تحولات فازی و خواص فازی سیستم Co/α-Fe₂O₃  سنتز شده به روش آلیاژسازی مکانیکی با نسبت های مولی متفاوت"، فصلنامه علمی پژوهشی مهندسی مواد مجلسی، شماره 6، 2، پاییز87.

 

[3]    S. Meng, Z. Yue, X. Zhang & L. Li, “Quasi-epitaxial barium hexaferrite thin films prepared by a topotactic reactive diffusion processˮ, Applied Surface Science, Vol. 290, pp. 340-345. 2013.

 

[4]    G. H. An, T. Y. Hwang, J. Kim, J. B. Kim, N. Kang, J. W. Jeon, M. Kang & Y. H. Cho, “Novel method for low temperature sintering of barium hexaferrite with magnetic easy-axis alignmentˮ, Journal of the European Ceramic Society, Vol. 34, pp. 1227-1233. 2014.

 

[5]    Q. Mohsen, “Barium hexaferrite synthesis by oxalate precursor route, Journal of Alloys and Compoundsˮ, Vol. 38, pp. 125-128. 2010.

 

[6]    M. Choi, S. Song, Y. Choi, D. Park & S. Kim, “Novel synthesizing method of BaFe₁₂O₁₉ microrod and its superior coercivity with shape anisotropyˮ, Materials Letters, Vol. 139, pp. 292-295. 2015.

 

[7]    Z. Liu, Q. C. Dai & j. M. Sun, “Efect of Ce-Co substitution on the magnetic properties of M-type barium hexaferiteˮ, J solid state commun, Vol. 152, pp. 849-860. 2012.

 

[8]    G. Asghar & M. Anis-ur-Rehman, “Structural, dielectric and magnetic properties of Cr-Zn doped strontium hexa-ferrites for high frequency applicationsˮ, J. Alloys Compd, Vol. 526, pp. 85-90. 2012.

 

[9]    Bsoul, S. H. Mahmood & A. F. Lehlooh, “Structural and magnetic properties of BaFe12TiXRuxO19ˮ, j. Alloys and Compd, Vol. 489, pp. 157-161. 2010.

 

[10] G. Zhu, Q. Yang, X. B. Shi, W. Z. Zheng & Y. L. Liu, “Solvo thermal fabrication and luminescent properties of Eu²⁺/Ce³⁺ doped barium lithium fluorideˮ, J. Rare Earths, Vol. 30, pp. 985-993. 2012.

 

[11] A. Francis & W. Daoush, “Synthesis and magnetic characteristics of crystallized ceramic in the BaO-NiO-TiO₂-Fe₂O₃systemˮ, J. Mater. Process. Technol, Vol. 181, pp. 213-218, 2007.

 

[12] R. Manisha, V. Bahadur, D. Kulkarni & S. D. Date, “S K Magnetic properties of Ni-Zr substituted barium ferriteˮ, J. Magn. Magn. Mater., Vol. 19, pp. 256-533. 1999.

 

[13] N. Muhammad, J. Muhammad, N. Muhammad, H. Pablo & M. Ashfaq, “Synthesis, magnetic and dielectric propertiesof Er-Ni doped Sr-hexaferrite nanomaterials for applications in high density recording media and microwavedevicesˮ, J. Magn. Magn. Mater, Vol. 324, pp. 15-30. 2012.

 

[14] Davoodi & B. Hashemi, “Magnetic properties of Sn-Mg substituted strontium hexaferrite nanoparticles synthesized via coprecipitation methodˮ, J. Alloys. Compd, Vol. 231, pp. 509-518. 2012.

 

[15] S. Kanagesan, S. Jesurani, R. Velmurugan, S. Prabu & T. Kalaivani, “Structural and magnetic properties of conventional and microwave treated Ni–Zr doped barium strontium hexaferriteˮ, Mater. Res. Bull, Vol. 47, pp. 188-193. 2012.

 

[16] H. Sozeri, A. Baykal & B. Unal, “Low-temperature synthesis of single-domain Sr-hexaferrite particles by solid-state reaction routeˮ, Phys. Status Solidi (A) Appl. Mater. Sci, Vol. 209, pp. 2002–2013, 2012.

 

[17] Sözeria, H. Deligözb & H. Kavasc, “H3443-3547., Baykal, A, Magnetic, dielectric and microwave properties of M–Ti substituted barium hexaferrites (M= Mn²⁺, Co²⁺, Cu²⁺, Ni²⁺, Zn²⁺) ˮ, Ceramics International, Vol. 37, pp. 234- 246. 2014.

 

[18] D. Lisjak & M. Drofenik, “Synthesis and characterization of A–Sn-sub-stituted (A¼Zn, Ni, Co) BaM–hexaferrite powders and ceramicsˮ, J. Eur. Ceram. Soc, Vol. 24, pp. 1841–1845. 2004.

 

[19] O. Akman, K. Kavas, A. Baykal, Z. Durmuş, B. Aktaş & H. Sözeri, “Microwave absorption properties of BaFe₁₂O19–TiO2 composite coated with conducting polymerˮ, J. Supercond. Novel Magn, Vol. 26, pp. 1369–1373, 2013.

 

[20] C. S. Wang, F. L. Wei, M. Lu, D. H. Han & Z. Yang, “Structure and magnetic properties of Zn–Ti-substituted Ba-ferrite particles for magnetic record-ingˮ, J. Magn. Magn. Mater, Vol. 183, pp. 241-250, 1998.

 

[21] Z. Yang, C. S. Wang, X. H. Li & H. X. Zeng, “(Zn, Ni, Ti) substituted barium ferrite particles with improved temperature coefficient of coercivityˮ, Mater. Sci. Eng, Vol. 90B, pp. 142–145, 2002.

 

[22] . Dho, J. Y. Park & N. H. Hur, “Effects of the grain boundary on the coercivity of barium ferritr BaFe₁₂O₁₉ˮ, J. Magn. Magn. Mater, Vol. 285, pp. 164–168, 2005.

 

[23] E. W. Gorter, “Ionic distribution deduced from the g-factor of a ferrimag-netic spinel: Ti⁴⁺ in fourfold co-ordinationˮ, Nature. Vol. 173, pp. 123–124, 1954.

 

[24] H. Sozeri, I. Küçük & H. Özkan, “Improvement in magnetic properties of La substituted BaFe₁₂O₁₉ particles prepared with an unusually low Fe/Ba molar ratioˮ, J. Magn. Magn. Mater. Vol. 323, pp. 1799–1804, 2011.

 

[25] Haq & M. Anis-ur-Rehman, “Effect of Pb on structural and magnetic properties of Ba-hexaferriteˮ, Physica, Vol. 407B, pp. 822–826, 2012.

 

[26] R. N. Summergrad & E. Banks, “New hexagonal ferrimagnetic oxidesˮ, J. Phys. Chem. Solids, Vol. 2, pp. 312-316, 1957.

 

[27] G. Turilli, F. Licci & S. Rinaldi, “Mn²⁺, Ti⁴⁺ substituted barium ferriteˮ, J. Magn. Magn. Mater, Vol. 59, pp. 127-135, 2005.

 

[28] Ghasemi, A. Hossienpour, A. Morisako, X. Liu & A. Ashrafizadeh, “Investigation of the microwave absorptive behavior of doped barium ferritesˮ, Mater. Des, Vol. 29, pp. 112–117. 2008.

 

[29] M. K. Tehrani, A. Ghasemi, M. Moradi & R. S. Alam, “Wideband electromagnetic wave absorber using doped barium hexaferrite in Ku-bandˮ, J. Alloys Compd, Vol. 509, pp. 83-91. 2011.

 

P. Wartewig, M. K. Krause, P. Esquinazi, S. Rosler & S. Sonntag, “Magnetic properties of Zn- and Ti-substituted barium hexaferriteˮ, J. Magn. Magn. Mater, Vol. 192, pp. 83-90, 1992.