Bioleaching operations of the Low-grade chalcopyrite ore in the chloride conditions using adapted Indigenous microorganisms

Subject Areas : Microbial Biotechnology

Ali  Behrad Vakylabad ¹ (Assistant Professor Ceramic Group, Department of Materials Science, Graduate University of Advanced Technology, Kerman, Iran.)
Peyman  Moha,mmadzadeh Jahani ² (Assistant professor, Department of Basic Sciences, School of medicine, Bam University of medical sciences, Bam, Iran.)
Zahra  Manafi ³ (M.Sc., Hydrometallurgy Research Unit, Research and Development Center, Sarcheshmeh Copper Complex, Rafsanjan, Iran)

Received: 2019-09-10 Accepted : 2019-10-19 Published : 2020-02-20

Keywords: Bioleaching, Indigenous microorganisms, Chloride adaptation of microbes, Low-grade chalcopyrite ore,

Abstract :

Background & Objectives: Dissolution of chalcopyrite is one of the most important challenges of hydrometallurgy because it is difficult to leach due to its inactivation by passive precipitates like jarosites. The combination of the benefits of microbial leaching (native mesophiles, moderate thermophiles, and extreme thermophiles), and chloride leaching was the main purpose to enhance the copper recovery, especially from the low-grade chalcopyrite sources. Materials & Methods: The native microorganisms were isolated from Sarcheshmeh mine, and adapted (4 months with chloride media). Then, the bioleaching operation was systematically performed using the columns containing low chalcopyrite ore (less than 0.3% Cu) to investigate the effect of the chlorine on the bioleaching process. Different analyzes of the leaching and feed residues were used to closely examine the process and mechanisms involved (A 23% increase in recovery (81% with chlorine and 58% with no chlorine)). Results: Based on the analyses of the bio-leaching residues, overcoming the problems caused by the unwanted precipitates like jarosite during chlorinated bioprocess (2 g / l chloride) was one of the main reasons for these results which were identified using SEM, EDS analysis. And, the elemental mapping of the solid residues from microbial leaching operations proved this possible reason. Conclusion: Controlling the undesirable precipitates in the process was the most important lever to improve copper recovery (more than 81% of copper over 120 days). This was achieved by regulating the growth process and activity of microorganisms from mesophiles to extreme thermophiles with sodium chloride salt additive.

References:

1. Madani K. Water management in Iran: what is causing the looming crisis? J Environ Studies Sci. 2014; 4
   (4): 315-328.
   2. Davis-Belmar C, Cautivo D, Demergasso C, Rautenbach G. Bioleaching of copper secondary sulfide ore
   in the presence of chloride by means of inoculation with chloride-tolerant microbial culture. Hydrometallurgy. 2014; 150: 308-312.
   3. Gao X, Yang Y, Pownceby MI, Zhong S, Chen M. A sulfur K-Edge XANES and raman study on the
   effect of chloride ion on bacterial and chemical leaching of chalcopyrite at 25° C. Mining, Metallurgy
   Explor. 2019; 36(2): 343-352.
   4. Vakylabad AB, Schaffie M, Naseri A, Ranjbar M, Manafi Z. Optimization of staged bioleaching of lowgrade chalcopyrite ore in the presence and absence of chloride in the irrigating lixiviant: ANFIS simulation. Bioprocess Biosystems Engin. 2016; 39(7): 1081-1104.
   5. Velásquez-Yévenes L, Torres D, Toro N. Leaching of chalcopyrite ore agglomerated with high chloride
   concentration and high curing periods. Hydrometallurgy. 2018; 181: 215-220.
   6. Zhao H, Zhang Y, Zhang X, Qian L, Sun M, Yang Y. The dissolution and passivation mechanism of
   chalcopyrite in bioleaching: An overview. Minerals Engin. 2019; 136: 140-154.
   7. Darezereshki E, Darban AK, Abdollahy M, Jamshidi-Zanjani A, Vakylabad AB, Mohammadnejad S.
   The leachability study of iron-oxides from mine tailings in a hybrid of sulfate-chloride lixiviant. J
   Environ Chem Eng. 2018; 6(4): 5167-5176.
   8. Hernández PC, Dupont J, Herreros OO, Jimenez YP, Torres CM. Accelerating copper leaching from
   sulfide ores in acid-nitrate-chloride media using agglomeration and curing as pretreatment. Minerals.
   2019; 9(4): 250.
   9. Castillo J, Sepúlveda R, Araya G, Guzmán D, Toro N, Pérez K. Leaching of white metal in a NaClH2SO4 system under environmental conditions. Minerals. 2019; 9(5): 319.
   10. Hidalgo T, Kuhar L, Beinlich A, Putnis A. Kinetics and mineralogical analysis of copper dissolution
   from a bornite/chalcopyrite composite sample in ferric-chloride and methanesulfonic-acid solutions.
   Hydrometallurgy. 2019.
   11. Khaleque HN, Kaksonen AH, Boxall NJ, Watkin EL. Chloride ion tolerance and pyrite bioleaching
   capabilities of pure and mixed halotolerant, acidophilic iron-and sulfur-oxidizing cultures. Minerals
   Engineering. 2018; 120: 87-93.
   12. Martins FL, Patto GB, Leão VA. Chalcopyrite bioleaching in the presence of high chloride
   concentrations. J Chem Technol Biotechnol. 2019.
   13. Vakylabad AB, Schaffie M, Naseri A, Ranjbar M, Manafi Z. A procedure for processing of pregnant
   leach solution (PLS) produced from a chalcopyrite-ore bio-heap: CuO Nano-powder fabrication.
   Hydrometallurgy. 2016; 163: 24-32.
   14. Robertson S, van Staden P, Seyedbagheri A. Advances in high-temperature heap leaching of
   refractory copper sulphide ores. J South Afr Institute Mining Metallurgy. 2012; 112(12): 1045-1050.
   15. Watling H. The bioleaching of sulphide minerals with emphasis on copper sulphides—a review.
   Hydrometallurgy. 2006; 84(1-2): 81-108.
   16. Vilcáez J, Inoue C. Mathematical modeling of thermophilic bioleaching of chalcopyrite. Minerals
   Eng. 2009; 22(11): 951-960.
   17. Dopson M, Lövgren L, Boström D. Silicate mineral dissolution in the presence of acidophilic
   microorganisms: implications for heap bioleaching. Hydrometallurgy. 2009; 96(4): 288-293.
   18. Senanayake G. A review of chloride assisted copper sulfide leaching by oxygenated sulfuric acid and
   mechanistic considerations. Hydrometallurgy. 2009; 98(1-2): 21-32.
   19. Vakylabad AB, Schaffie M, Ranjbar M, Manafi Z, Darezereshki E. Bio-processing of copper from
   combined smelter dust and flotation concentrate: A comparative study on the stirred tank and airlift
   reactors. J Hazardous Materials. 2012; 241: 197-206.
   20. Vakylabad AB, Ranjbar M, Manafi Z, Bakhtiari F. Tank bioleaching of copper from combined
   flotation concentrate and smelter dust. Int Biodeterior Biodegrad. 2011; 65(8): 1208-1214.
   21. Vakylabad AB. A comparison of bioleaching ability of mesophilic and moderately thermophilic
   culture on copper bioleaching from flotation concentrate and smelter dust. Int J of Mineral
   Processing. 2011; 101(1-4): 94-99.
   22. Pakostova E, Grail BM, Johnson DB, editors. Column bioleaching of a saline, calcareous copper
   sulfide ore. Solid State Phenomena; 2017.
   23. Hawkes RB, Franzmann PD, O’hara G, Plumb JJ. Ferroplasma cupricumulans sp. nov., a novel
   moderately thermophilic, acidophilic archaeon isolated from an industrial-scale chalcocite bioleach
   heap. Extremophiles. 2006; 10(6): 525-530.
   24. Leahy M, Davidson M, Schwarz M. A model for heap bioleaching of chalcocite with heat balance:
   mesophiles and moderate thermophiles. Hydrometallurgy. 2007; 85(1): 24-41.
   25. Petersen J, Dixon DG. Principles, mechanisms and dynamics of chalcocite heap bioleaching.
   Microbial processing of metal sulfides: Springer; 2007. p. 193-218.
   26. Xingyu L, Biao W, Bowei C, Jiankang W, Renman R, Guocheng Y. Bioleaching of chalcocite
   started at different pH: Response of the microbial community to environmental stress and leaching
   kinetics. Hydrometallurgy. 2010; 103(1-4): 1-6.
   27. Hawkes RB, Franzmann PD, Plumb JJ. Moderate thermophiles including “Ferroplasma
   cupricumulans” sp. nov. dominate an industrial-scale chalcocite heap bioleaching operation.
   Hydrometallurgy. 2006; 83(1-4): 229-236.
   28. Bobadilla-Fazzini RA, Pérez A, Gautier V, Jordan H, Parada P. Primary copper sulfides bioleaching
   vs. chloride leaching: Advantages and drawbacks. Hydrometallurgy. 2017; 168: 26-31.
   29. Lu Z, Jeffrey M, Lawson F. The effect of chloride ions on the dissolution of chalcopyrite in acidic
   solutions. Hydrometallurgy. 2000; 56(2): 189-202.
   30. Lu Z, Jeffrey M, Lawson F. An electrochemical study of the effect of chloride ions on the dissolution
   of chalcopyrite in acidic solutions. Hydrometallurgy. 2000; 56(2): 145-155.
   31. Dutrizac J. Elemental sulphur formation during the ferric chloride leaching of chalcopyrite.
   Hydrometallurgy. 1990; 23(2-3): 153-176.
   32. Tao H, Dongwei L. Presentation on mechanisms and applications of chalcopyrite and pyrite
   bioleaching in biohydrometallurgy – a presentation. Biotechnol Report. 2014; 4: 107-119.
   33. Akcil A, Ciftci H, Deveci H. Role and contribution of pure and mixed cultures of mesophiles in
   bioleaching of a pyritic chalcopyrite concentrate. Minerals Eng. 2007; 20(3): 310-318.
   34. Tao H, Dongwei L. Presentation on mechanisms and applications of chalcopyrite and pyrite
   bioleaching in biohydrometallurgy–a presentation. Biotechnol Report. 2014; 4: 107-119.
   35. Rawlings D, Tributsch H, Hansford G. Reasons why'Leptospirillum'-like species rather than
   Thiobacillus ferrooxidans are the dominant iron-oxidizing bacteria in many commercial processes for
   the biooxidation of pyrite and related ores. Microbiol Reading. 1999; 145(1): 5-14.
   36. Petersen J, Dixon D. Thermophilic heap leaching of a chalcopyrite concentrate. Minerals Eng. 2002;
   15(11): 777-785.