Operational Conditions of Micronized Maize Grains Assessed by Modeling Ruminal in vitro Gas Production Data and Three Steps Method
الموضوعات :
R. Samsami
1
(
Department of Animal Science, Faculty of Agriculture, Ferdowsi University of Mashhad, Mashhad, Iran
)
A. Rohani
2
(
Department of Biosystems Engineering, Faculty of Agriculture, Ferdowsi University of Mashhad, Mashhad, Iran
)
V. Heidarian Miri
3
(
Faravardaneh Ferdowsi Mashhad, Incubator Centre, Ferdowsi University of Mashhad, Mashhad, Iran
)
س.ه. ابراهیمی
4
(
گروه علوم دامی، دانشکده کشاورزی، دانشگاه فردوسی مشهد
)
الکلمات المفتاحية: non-linear models, infrared radiation, grains micronization, small intestine di-gestibility,
ملخص المقالة :
Micronization of grains is an energy-consuming heat-based process and reducing treatment time in this method might be economically desirable. Different operational conditions including duration of the process (s), grain surface temperature at the end of the process (˚C), and distance between grain and burner (cm) in a micronizer machine were examined to assess the possibility of reducing processing time using in vitro gas production, in situ and enzymatic dry matter digestibility of corn grains. Treatments which were made by altering the above operational conditions in order included: Mic 1 (120 s, 155 ˚C, and 35 cm), Mic 2 (60 s, 155 ˚C, and 15 cm), Mic 3 (90 s, 165 ˚C, and 15 cm) and Mic 4 (120 s, 175 ˚C, and 15 cm). There were two batches of raw corn which were included Raw 1 and Raw 2 as the control for micronized corn grains (Mic 1, and Mic 2-Mic 4), respectively. Enzymatic dry matter (DM) digestibility in micronized corn grains (Mic 1=26.46 and Mic 3=29.27) was significantly (P<0.001) greater than their representative controls (Raw 1=22.17 and Raw 2=25.68) but increasing severity of the process, enhanced ruminal disappearance of dry matter (66.27 vs. 59.32 in Mic 4 and Raw 2, respectively. Out of 11 non-linear tested models, logistic-exponential without lag (LE0) showed the best performance for fitting gas production results indicated that the extent of gas production may decrease or increase by micronization depending upon the operational conditions. Overall, if the surface temperature of radiated grains at exiting (as a major indicator) is fixed and could be achieved by changing micronizer structure within a shorter time, similar in vitro and in situ performance in radiated corn grains can be obtained however, overheating may increase risk of ruminal acidosis.
AOAC. (2005). Official Methods of Analysis. 17th Ed. Association of Official Analytical Chemists, Arlington, Washington, DC., USA.
Ebrahimi S.H. (2020). Feeding complete concentrate pellets containing ground grains or blend of steam-flaked grains and other concentrate ingredients in ruminant nutrition: A review. Ann. Anim. Sci. 20, 11-28.
Eckhoff S.R. (2004). MAIZE | wet milling. Pp. 225-241 in Encyclopedia of Grain Science. W. Colin, H. Cooke and C.E. Walker, Eds. Elsevier, Oxford, United Kingdom.
Emami S., Meda V., Pickard M.D. and Tyler R.T. (2010). Impact of micronization on rapidly digestible, slowly digestible, and resistant starch concentrations in normal, high-amylose, and waxy barley. J. Agric. Food Chem. 58, 9793-9799.
FAO. (2018). Food Outlook-Biannual Report on Global Food Markets. Food and Agriculture Organization of the United Nations (FAO), Rome, Italy.
Fasina O.O., Tyler R.T., Pickard M.D. and Zheng G.H. (1999). Infrared heating of hulless and pearled barley. J. Food Pro. Preserv. 23, 135-151.
Fattah A., Sadeghi A.A., Nikkhah A., Chamani M. and Shawrang P. (2013). Degradation characteristics of infrared processed barley grain and its feeding effects on ruminal pH of sheep. Iranian J. Appl. Anim. Sci. 3, 451-457.
Ferraretto L.F., Crump P.M. and Shaver R.D. (2013). Effect of cereal grain type and corn grain harvesting and processing methods on intake, digestion, and milk production by dairy cows through a meta-analysis. J. Dairy Sci. 96, 533-550.
Gallo A., Giuberti G., Atzori A.S. and Masoero F. (2018). Short communication: In vitro rumen gas production and starch degradation of starch-based feeds depend on mean particle size. J. Dairy Sci. 101, 6142-6149.
Humer E. and Zebeli Q. (2017). Grains in ruminant feeding and potentials to enhance their nutritive and health value by chemical processing. Anim. Feed Sci. Technol. 226, 133-151.
Loy D.D. and Lundy E.L. (2019). Nutritional properties and feeding value of corn and its coproducts. Pp. 633-659 in Corn: Chemistry and Technology. S.O. Serna Saldivar, Ed. AACC International Press, Oxford, United Kingdom.
Makeri M.U., Mohamed S.A., Karim R., Ramakrishnan Y. and Muhammad K. (2017). Fractionation, physicochemical, and structural characterization of winged bean seed protein fractions with reference to soybean. Int. J. Food Prop. 20(S2), 2220-2236.
McAllister T.A. and Sultana H. (2011). Effects of micronization on the in situ and in vitro digestion of cereal grains. Asian-Australasian J. Anim. Sci. 24, 929-939.
Menke K. and Steingass H. (1988). Estimation of the energetic feed value obtained from chemical analysis and in vitro gas production using rumen fluid. Anim. Res. Dev. 28, 7-55.
Miraei Ashtiani S.H., Rohani A. and Aghkhani M.H. (2020). Soft computing-based method for estimation of almond kernel mass from its shell features. Sci. Hortic. 262, 109071-109080.
Muetzel S., Hunt C. and Tavendale M.H. (2014). A fully automated incubation system for the measurement of gas production and gas composition. Anim. Feed Sci. Technol. 196, 1-11.
Ngonyamo-Majee D., Shaver R.D., Coors J.G., Sapienza D. and Lauer J.G. (2009). Influence of single-gene mutations, harvest maturity and sample processing on ruminal in situ and post-ruminal in vitro dry matter and starch degradability of corn grain by ruminants. Anim. Feed Sci. Technol. 151, 240-250.
Niu Z.Y., Classen H.L. and Scott T.A. (2003). Interaction of wheat micronization and cultivar on its feeding value for broilers. Canadian J. Anim. Sci. 83, 123-129.
Rose R., Rose C.L., Omi S.K., Forry K.R., Durall D.M. and Bigg W.L. (1991). Starch determination by perchloric acid vs enzymes: evaluating the accuracy and precision of six colorimetric methods. J. Agric. Food Chem. 39, 2-11.
Ryšavá B. (1994). Proteins and amino acids in maize kernels. Pp. 555-570 in Maize-Biotechnology in Agriculture and Forestry. Y.P.S. Bajaj, Ed. Springer, Berlin, Heidelberg.
SAS Institute. (2004). SAS®/STAT Software, Release 9.4. SAS Institute, Inc., Cary, NC. USA.
Wang M., Tang S.X. and Tan Z.L. (2011). Modeling in vitro gas production kinetics: Derivation of Logistic–Exponential (LE) equations and comparison of models. Anim. Feed Sci. Technol. 165, 137-150.
Zarkadas L. and Wiseman J. (2001). Influence of processing variables during micronization of wheat on starch structure and subsequent performance and digestibility in weaned piglets fed wheat-based diets. Anim. Feed Sci. Technol. 93, 93-107.
Zarzycki P., Sobota A., Kuzawińska E., Wirkijowska A. and Sykut-Domańska E. (2017). Estimation of degree of starch gelatinisation in instant pasta using measurements of viscosity and water absorption of ground instant pasta dispersions. Acta Agrophys. 24, 625-632.
Žilić S., Šukalović V.H.T., Milašinović M., Ignjatović-Micić D., Maksimovć M. and Semenćenko V. (2010). Effect of micronisation on the composition and properties of the flour from white, yellow and red maize. Food Technol. Biotechnol. 48, 198-206.
Zinn R.A., Owens F.N. and Ware R.A. (2002). Flaking corn: Processing mechanics, quality standards, and impacts on energy availability and performance of feedlot cattle. J. Anim. Sci. 80, 1145-1156.
