Investigation the effects of bacterial additive and moisture absorbent on the fermentability and nutrient composition of potato silage
Mehran Jalili
1
(
Department of Animal Science, Faculty of Agriculture, University of Tabriz, Tabriz, Iran
)
Hamid Mohammadzadeh
2
(
Department of Animal Science, Faculty of Agriculture, University of Tabriz, Tabriz, Iran
)
علی حسینخانی
3
(
دانشیار گروه علوم دامی دانشکده کشاورزی دانشگاه تبریز
)
اکبر تقی زاده
4
(
استاد گروه علوم دامی دانشکده کشاورزی دانشگاه تبریز
)
Keywords: starch, aerobic stability, lactic acid, Bacterial inoculant, Dry matter recovery,
Abstract :
Potato dry matter is mainly composed of starch, which can be used in animal feed due to its high available energy. This study aimed to improve the quality of potato silage using wheat straw and additives containing Lactobacillus. This study was conducted in a completely randomized design with 4 treatments and 3 replications: 1- Potatoes without additives, control, (PS), 2- Potatoes mixed with wheat straw (90:10 ratio on a fresh basis) (PWS), 3- Potatoes inoculated with SiloOne additive (including Lactobacillus buchneri, Lactobacillus plantarium, Enterococcus faecium, Lactobacillus acidophilus, Lactic acid pediococcus and multivalent enzyme), (PLS), 4- Sliced potatoes with wheat straw (90:10 ratio on a fresh basis) and SiloOne additive (PWLS). The samples were stored in laboratory silos for 60 days at a temperature of 25 degrees Celsius. According to the results, there was a significant difference between the treatments in terms of pH, dry matter (DM), ash and insoluble fiber in neutral and acidic detergents. The addition of wheat straw reduced the loss caused by silage effluent and increased DM recovery (P<0.01). The lactic acid concentration of inoculated silages (PLS and PWLS) was greater than non-inoculated silages (P<0.01). The lowest concentrations of acetic acid and propionic acid were observed in the treatment with wheat straw in the absence of lactic acid bacteria (LAB) (PWS) (P<0.05). Concentrations of valeric acid and iso-valeric acid were not affected by wheat straw and inoculation with LAB (P>0.05).
Investigation the effects of bacterial Additive and Moisture Absorbent on the Fermentability and Nutrient composition of potato silage
M. Jalili 1, H. Mohammadzadeh 2*, A. Hossein-Khani 3 and A. Taghizadeh 4
MSc Student, Department of Animal Science, Faculty of Agriculture, University of Tabriz, Tabriz, Iran 1
Assistant Professor, Department of Animal Science, Faculty of Agriculture, University of Tabriz, Tabriz, Iran 2
Associate Professor, Department of Animal Science, Faculty of Agriculture, University of Tabriz, Tabriz, Iran 3
Professor, Department of Animal Science, Faculty of Agriculture, University of Tabriz, Tabriz, Iran 4
* Corresponding author: E mail: hamidmhz@tabrizu.ac.ir
Abstract
Potato dry matter is mainly composed of starch, which can be used in animal feed due to its high available energy. This study aimed to improve the quality of potato silage using wheat straw and additives containing Lactobacillus. This study was conducted in a completely randomized design with 4 treatments and 3 replications: 1- Potatoes without additives, control, (PS), 2- Potatoes mixed with wheat straw (90:10 ratio on a fresh basis) (PWS), 3- Potatoes inoculated with SiloOne additive (including Lactobacillus buchneri, Lactobacillus plantarium, Enterococcus faecium, Lactobacillus acidophilus, Lactic acid pediococcus and multivalent enzyme), (PLS), 4- Sliced potatoes with wheat straw (90:10 ratio on a fresh basis) and SiloOne additive (PWLS). The samples were stored in laboratory silos for 60 days at a temperature of 25 degrees Celsius. According to the results, there was a significant difference between the treatments in terms of pH, dry matter (DM), ash and insoluble fiber in neutral and acidic detergents. The addition of wheat straw reduced the loss caused by silage effluent and increased DM recovery (P<0.01). The lactic acid concentration of inoculated silages (PLS and PWLS) was greater than non-inoculated silages (P<0.01). The lowest concentrations of acetic acid and propionic acid were observed in the treatment with wheat straw in the absence of lactic acid bacteria (LAB) (PWS) (P<0.05). Concentrations of valeric acid and iso-valeric acid were not affected by wheat straw and inoculation with LAB (P>0.05). The results of this study showed that ensiling potatoes with a wheat straw reduces silage effluent losses and increases DM recovery. But the fermentation quality and aerobic stability of PWS were lower than PS. However, LAB inoculation improved the fermentation quality of PWS. The use of wheat straw along with LAB inoculation increased the ratio of lactic acid to total VFA.
Keywords: Aerobic stability, Bacterial inoculant, Dry matter recovery, Lactic acid, Starch
1. Introduction
Potato with the scientific name of Solanum tuberosom is an annual plant of the Solanaceae family (Pazhouhandeh et al., 2017) and one of the most important crops in the world after wheat and rice ( et al, 2022). Potatoes are used for human consumption and are not grown as animal feed, but every year part of the potato crop is lost due to overproduction and also as waste, which causes damage to farmers and environmental pollution. Iran is one of the top 20 potato-producing countries with a production of about 4.5 million tons of potatoes per annum (FAOSTAT, 2020.(
Potatoes are a rich source of starch, which usually makes up 25 to 90% (Barrell et al, 2013). Potato starch has larger granules compared to cereal starch and usually has an average diameter of 20 to 40 microns (Peshin, 2001). This property makes this material highly gelatinous and swells at a lower temperature. When potato starch granules become gelatinous, they swell significantly and break as a result. Cereal granules also swell, but do not reach the rupture stage (McDonald et al, 2010). Yusuph et al (2003) reported that potato starch amylose levels were about 29.0% and the amylose to amylopectin ratio was 1: 2.42 on average, indicating high levels of amylose. Amylose is difficult to degrade and its molecular shape makes it difficult to gelatinize starch (da Silva Figueiró et al. 2022).
During the peak production season, farmers are faced with the problem of disposing of surplus potatoes. Every year, part of the potato crop is wasted due to traditional harvesting in the fields, lack of cold storage and non-standard storage (Pringojin et al. 2003). For this reason, part of the annual potato production is no longer suitable for human consumption and part of it can be used as feed for livestock (Bradshaw et al. 2002). Its use in livestocks is limited due to its high humidity. One of the ways that farmers can be suggested in high-yield seasons is to either silage the surplus potato crop alone or to silage it with one of the forage types. The most important factor in ensuring the success of fermentation is that the potato is not mixed with the soil during ensiling and its green buds are separated from it due to the high solanine content (Halliday 2015).
Due to the seasonal production and low shelf life of potatoes, the need to use processes that enable us to provide this product all year round seems necessary. Forage storage in the form of silage is a common method of providing ruminant feed sources at times of the year when fresh forage is not available. In this method, due to the activity of lactic acid-producing bacteria and under anaerobic conditions, water-soluble carbohydrates in forage water are converted to organic acids (mainly lactic acid) and reduce the pH and thus protect forage from microbial spoilage (Filya 2003).
Ensiling plant products with high humidity by losing large amounts of digestible nutrients through leakage reduces the nutritional value of silage for livestock, and the effluent from it can also cause environmental pollution (Zhang et al, 2012). Therefore, adding moisture absorbent materials such as wheat straw to potato silos can prevent the loss of nutrients in the silage effluent. Since potatoes must be washed before ensiling, the population of Lactobacillus in it is reduced, which to provide a sufficient population of LAB, it is necessary to add microbial additives containing these microorganisms to the shredded potatoes during silage. By using bacterial additives containing several strains of homogeneous bacteria, the actual synergistic activity between different strains can be used. Microbial additives from selected species of homogeneous lactic acid-producing bacteria such as Lactobacillus plantarum, Pediococcus and Enterococcus are good choices. Because several organisms differ in terms of growth rate, fermentation products and optimal growth conditions are used in the additive (Khorvash et al. 2014). It is expected that the use of wheat straw and SiloOne microbial additive will improve the quality of silage by reducing effluent production, proper fermentation and increasing the rate of pH drop.
2. Materials and methods
2.1. Silage preparation and treatment
The potatoes variety Agria was procured from the local market and transferred to the Khalatpooshan laboratory unit of Tabriz University. After washing the potatoes and ensuring that they were free from soil contamination, they were chopped into 2-3 cm pieces using a kitchen knife. Chopped potatoes allocated in four treatments including: 1- Potatoes without additives, control, (PS), 2- Potatoes mixed with wheat straw (90:10 ratio on a fresh basis), (PWS), 3- Potatoes inoculated with bacterial additive SiloOne, (Fidar Damdare Bartar Ariyayee company in Iran); Contains Lactobacillus buchneri, Lactobacillus plantarum, Enterococcus faecium, Lactobacillus acidophilus, Lactic acid pediococcus and multivalent enzyme, (PLS) 4- Potatoes mixed with 10% wheat straw, which inoculated with bacterial additive SiloOne, (PWLS). The prepared mixture for each treatment was ensiled in three replications. For this purpose, laboratory silos were used, which included PVC pipes with a diameter of 10 cm and a length of 56 cm. The capacity of these silos is about 5 kg, which has a drain valve to remove the leachate. The ingredients were thoroughly mixed by hand. The silos were gradually filled with potatoes, pounded and compressed at the same time, and finally, the silos were closed with metal clamps so that air does not penetrate into them. During the 60-day storage period, the silos were regularly weighed and the effluent produced was measured.
2.2. Chemical analyses
Starch, dry matter percentage, ash content and NDF and ADF of potatoes were determined before ensiling. After 60 days, all silos were opened and evaluated and sampled. Sampling was performed from a depth of 10 cm of silos. For this purpose, three samples were taken from each replication. After decanting the silage extract, pH, ammonia nitrogen, soluble carbohydrates, lactic acid and VFAs were determined. Another sample was used to determine chemical composition (dry matter, raw ash, pectin, NDF and ADF) and the third sample was used to measure aerobic stability. Hemicellulose content was calculated by difference as: Hemicellulose = NDF – ADF.
Simultaneously, the apparent quality of silage was evaluated using odor, texture and color indices by sensory method (Killek. 1986). The pH value was measured using a pH meter (model CG 804-Germany). Flieg points were calculated using the pH and DM values of the silos at the end of the fermentation period with the following equation (Killek. 1986):
Flieg points = 220 + (2 ×% DM − 15) - 40 × pH
Flieg index scores; A silo was considered very bad when it had a score of less than 20. poor quality with a score between 21 and 40; average with a score between 41 and 60; Being well with a score of 61 to 80 and being very well when it is between 81 and 100.
The dry matter content of the samples was determined using an oven for 72 hours at 55 ° C (Van Soest et al. 1991). Crude ash was determined by incineration in an electric furnace (AOAC. 2005). The NDF and ADF were determined according to Van Soest et al. (1991). Potato starch was measured using a centrifuge method (Yusupha et al. 2003). Ammonia nitrogen and water-soluble carbohydrates were measured by spectrophotometry and Volatile fatty acids and lactic acid were measured by the use of high performance lipid chromatography (HPLC) (Wang et al. in 2021).
2.3. Aerobic stability
To measure the aerobic stability of silages, 1000 g of each silage mixture was placed in plastic buckets and covered with a two-layer Cheesecloth. The thermometer was placed in the middle of the bucket inside the silo mass and the silage and ambient temperature were measured every two hours. When the temperature of the silage reached 2 °C higher than the ambient temperature, the silages were considered as rotten and moldy silage (Nishino et al. 2003).
2.4. Statistical analyses
The obtained data were analyzed completely randomly with 4 treatments and 3 replications for each treatment using SAS statistical program (Version 9.2; SAS Inst. USA, 2009) and Tukey test (at 5% level) was used to compare the means.
Yij = µ+Ti + eij
Where Yij is the general observation, μ the overall mean, Ti the effect of treatment, eij experimental error effect.
3. Results and discussion
3.1. Chemical Composition
The chemical composition of raw potatoes with or without wheat straw is reported in Table 1.
Table 1- Chemical composition of raw potatoes before ensiling (%DM) | ||
Fresh Potato +10% wheat straw | Fresh Potato | Items* |
25.67±0.60 | 21.07±0.50 | DM |
5.45±0.14 | 4.69±0.29 | Ash |
30.70±1.56 | 6.9±0.14 | NDF |
29.12±1.09 | 2.32±0.24 | ADF |
1.58±0.69 | 4.58±0.58 | HC |
77.13±1.27 | 87.63±1.63 | Starch |
* DM, Dry matter; NDF, Neutral detergent fiber; ADF, Acid detergent fiber; HC, Hemicellulos. | ||
The results of chemical analysis showed that the addition of wheat straw increased the percentage of dry matter and ash, NDF and ADF of potatoes.
Table 2- The effect of wheat straw and SiloOne additive on the chemical properties of potato silage (%DM) | ||||||
P-VALUE | SEM | Treatments** | Items* | |||
PWLS | PLS | PWS | PS | |||
0.0001 | 0.038 | 5.08 b | 4.74 d | 5.24 a | 4.91 c | pH |
0.0005 | 0.507 | 35.41 a | 35.51 a | 33.08 b | 36.46 a | DM |
0.0001 | 0.083 | 4.25 a | 2.27 b | 4.28 a | 2.21 b | Ash (%DM) |
0.0001 | 0.832 | 16.62 a | 1.63 b | 16.43 a | 1.00 b | NDF (%DM) |
0.0001 | 0.362 | 8.65 b | 0.32 d | 9.43 a | 0.37 c | ADF (%DM) |
0.0001 | 0.854 | 7.97 a | 1.31 b | 7.01 a | 0.63 b | HC (%DM) |
0.7805 | 3.963 | 57.03 | 57.26 | 60.56 | 59.38 | Starch (%DM) |
0.0001 | 1.214 | 72.62 b | 86.64 a | 61.71 b | 81.51 a | Flieg points |
* DM, Dry matter; NDF, Neutral detergent fiber; ADF, Acid detergent fiber; HC, Hemicelluloses. ** PS = Potato Silage; PWS = Potato-Wheat Straw Silage; PLS = Potato -Lactobacillus Silage; PWLS = Potato-Wheat Straw-Lactobacillus Silage. | ||||||
As shown in Table 2, The addition of wheat straw to potato silage caused a significant increase in pH (P<0.01), so potato silage with wheat straw had the highest pH in the absence of SiloOne additive (PWS). Because adding wheat straw to potatoes decreased the concentration of lactic and acetic acids and increased the concentration of ammonia nitrogen and butyric acid compared to other treatments (Table 4). Babaeinasab et al. (2015) used different additives in potato silage and observed that the potato-wheat straw silage mixture without any additives had the highest pH. The addition of LAB to potato silage (PLS) caused a significant decrease in pH because it increased the lactic acid of potato silage (Table 4). Ash, NDF and ADF values were significantly greater for treatments containing wheat straw compared to the control group (PS) (P<0.01). Since the percentage of minerals, NDF and ADF in wheat straw are high, adding it to potato silage increases ash and cell wall. The level of DM in the treatments containing wheat straw without the addition of SiloOne (PWS) was reduced compared to the control group (P<0.01). which can be due to the high water holding capacity of wheat straw, which preserves the moisture content of silages containing wheat straw, while a significant part of the moisture in silages without wheat straw (PS, PLS) was lost in the form of effluents (Table 5).
The lower the pH and the higher the dry matter in the silage, the better the score will be in terms of the Flieg point. Among the treatments in terms of the Flieg point, the treatment containing microbial additive alone (PLS) along with the control treatment (PS) scored very well in terms of the flag index. The addition of wheat straw to potato silage significantly reduced Flieg point (P<0.01). Because high pH reduces Flieg point.
Starch is the main carbohydrate of potatoes (Xia et al. 2021). The initial content of starch in potatoes was reported to be 87/63% of dry matter (Table 1). There was no significant difference in the amount of starch among the treatments, although the loss of starch in inoculated silages (PWLS and PLS) was higher than that of non-inoculated silages, but this reduction was not significant (P>0.05). In similar studies, the starch content of cooked potatoes after 42 days of DM silage was 21% (Lindahl et al. 1946). This difference in starch losses in raw and cooked potato silage is because heat treatment with sufficient water causes gelatinization, which increases the sensitivity to starch decomposition (Svihus et al. 2005). Because potato starch contains long-chain amylopectin (Chung and Liu. 2010), it needs more energy to gelatinize (Jane et al. 1999). In another study, the starch content of potato pulp decreased after 50 days of silage; potato pulp silo without Lactobacillus additive (control group) reported the least starch degradation (Okine et al. 2005). Loss of potato starch at neutral or low pH is due to microbial function (Sauter et al. 1979). However, due to the losses due to silo effluent, losses due to bacterial hydrolysis were not significant in this study. Most LAB could not use starch directly because starch, unlike fructans, is slightly soluble in cold water (Narita et al. 2004). Also, compared to other starch sources, potato starch has the highest resistance to hydrolysis, because the size of large granules of potato starch makes it resistant to hydrolysis (Rocha et al. 2010).
3.2. Appearance quality
Silage can be classified based on appearance and parameters such as color, odor and structure. Color is an important property that reflects the quality of the silage. The color of raw potatoes was yellow after slicing, and 60 days after silage, we saw a uniform yellow color in high-quality silages. Light color (yellow) was considered the optimal condition of silages and darker colors (brown, black) indicated the unfavorable condition of silage.
Table 3- The effect of wheat straw and SiloOne additive on the appearance quality of potato silage | ||||||
P-VALUE | SEM | Treatments* | Items | |||
PWLS | PLS | PWS | PS | |||
1.576 | 0.873 | 5.00 | 3.33 | 5.00 | 4.67 | Color (5) |
0.0053 | 0.512 | 3.50 a | 1.33 c | 3.00 ab | 1.67 bc | Smell (5) |
0.0292 | 0.534 | 4.33 a | 3.33 ab | 4.33 a | 2.67 b | Structure (5) |
|
|
|
|
|
|
|
0.0188 | 1.472 | 12.83 a | 7.99 b | 12.33 a | 9.01 b | Total score (15) |
* PS = Potato Silage; PWS = Potato-Wheat Straw Silage; PLS = Potato -Lactobacillus Silage; PWLS = Potato-Wheat Straw-Lactobacillus Silage. | ||||||
The smell of silage is another feature that can be sensory assessed. None of the silages smelled good, and basically the potato silage smelled bad. But in good quality silages, the special smell of lactic acid could be inhaled.
In this experiment, the appearance of the silages showed the optimal condition of the silages. Assessments based on silage color ranged from 5 to 1, including white or light yellow, brownish yellow, brown, dark brown, black, or charcoal. Assessments based on silage smell ranged from 5 to 1, respectively, including vinegar odor, an odorless, mild odor of vinegar and leftover potatoes, bad odor, and a very bad odor. Immortality based on structure and texture ranged from 5 to 1, respectively: hard, softer, viscous, moldy silage. Based on the available results, treatments containing wheat straw alone or with bacterial inoculation (PWLS) had the highest total score in the sensory evaluation by sensory method (P<0.05). The treatment containing microbial additive alone (PLS) had the lowest total score in terms of appearance.
3.3. Fermentation characteristics
Fermentation properties of silos were affected by additives after 60 days, the results are reported in Table 4.
Table 4 - The effect of wheat straw and SiloOne additive on the fermentation characteristics of potato silage | ||||||
P-VALUE | SEM | Treatments** | Items* | |||
PWLS | PLS | PWS | PS | |||
0.2354 | 0.620 | 5.45 | 4.71 | 5.64 | 5.80 | NH3-N (mmol /100 mol) |
0.0755 | 0.065 | 1.04 | 0.91 | 0.92 | 1.04 | WSC (mmol /100 mol) |
0.0007 | 1.364 | 39.98 a | 39.95 a | 23.48 b | 37.17 a | Lactic Acid (mmol /100 mol) |
0.0091 | 0.757 | 48.55 a | 44.50 cd | 43.89 d | 47.41 bc | AA (mmol /100 mol) |
0.0402 | 1.494 | 5.37 ab | 8.69 a | 4.73 b | 10.91 a | PA (mmol /100 mol) |
0.0001 | 0.965 | 3.5.8 b | 4.40 b | 24.47 a | 1.94 b | BA (mmol /100 mol) |
0.2079 | 0.371 | 0.81 | 1.62 | 1.71 | 1.31 | VA (mmol /100 mol) |
0.1507 | 0.309 | 0.88 | 1.64 | 1.71 | 1.25 | IVA (mmol/100 mol) |
0.0032 | 0.039 | 0.82 a | 0.91 a | 0.53 b | 0.78 ab | AA : LA |
0.0014 | 0.035 | 0.67 a | 0.66 a | 0.31 b | 0.59 a | LA: VFA |
* NH3-N, Ammonia nitrogen.; WSC, water soluble carbohydrates; AA, Acetic Acid; PA, Propionic Acid; BA, Butyric Acid; VA, valeric Acid; IVA, IsoValeric Acid; VFA, Volatile fatty acids. ** PS = Potato Silage; PWS = Potato-Wheat Straw Silage; PLS = Potato -Lactobacillus Silage; PWLS = Potato-Wheat Straw-Lactobacillus Silage. | ||||||
No significant difference was observed in terms of ammonia nitrogen among the treatments, although the treatment containing the microbial additive without wheat straw (PLS) had the lowest concentration of ammonia nitrogen. Because the PLS treatment had the lowest pH (Table 2). Low pH in the early stages of silage can inhibit the protease activity of plant enzymes and bacteria (Driehuis et al. 1999) Lower ammonia nitrogen values indicate better silage quality. Because ammonia nitrogen production is related to CP degradation of silage, which reveals the extent of proteolysis in silage (McDonald et al, 1991). High pH in the control treatment and treatments containing wheat straw alone (PWS) or inoculated (PWLS) provided suitable conditions for protease activity of plant enzymes and bacteria, which increased the level of ammonia nitrogen in these silages. water-soluble carbohydrates (WSC) is the essential substrate for the growth of lactic acid-producing bacteria (LAB) in the fermentation process. Potato silage contains few WSC, which led to poor silage fermentation (Table 4). Because silo effluents contain WSC, they usually result in the loss of large amounts of digestible nutrients through leaching (McDonald et al. 1991). WSC is best used by lactic acid bacteria (LAB) in inoculated silage (Nkosi et al. 2010).
The concentration of lactic acid in inoculated silages (PWLS and PLS) was greater than in non-inoculated silages (PWS) (P<0.01). The amount of lactic acid produced was not enough to reach the desired pH in the PWS (Table 2). Because the pH of the silage increases with decreasing lactate (Borreani et al. 2018). Adding LAB to PWS increased lactic and acetic acid concentrations and decreased butyric acid concentrations (P< 0.05). Potato starch contains higher amounts of long-chain amylose and amylopectin, resulting in a higher crystalline region with less hydrolysis (Wang et al. 2022). On the other hand, high pH during silage reduces the production of lactic acid from starch because high pH reduces acid hydrolysis and shorter chains, the crystal structure is not reduced and digestibility is reduced (Lee et al. 2018).
Some species produce Lactobacillus, amylase extracellularly and ferment starch directly to lactic acid. The amylolytic activity of the fermenting organism is a key feature of the fermentation of starch to lactic acid (Reddy et al. 2008). However, the amylolytic activity of microorganisms has less effect on the removal of starch that decomposes slowly (Monteils et al. 2002). WSCs are essential resources for LAB growth in the fermentation process (McDonald et al, 1991). High silage effluents (Table 5) reduce these resources because nutrients such as soluble sugars decompose faster than low-nutrient materials such as lignin, hemicellulose, and cellulose (Savoie-Jofriet, 2003) resulting in lactic acid production Being reduced. Adding wheat straw to potato silage (PWS) caused a significant decrease in propionic acid (P<0.05). The addition of LAB to PWS caused a significant increase in propionic acid (P<0.05). The concentration of butyric acid increased under the influence of wheat straw (P<0.01). Because High humidity and pH in PWS stimulate the growth of Clostridium (Table 2). C a large population of clostridial bacteria prevails instead of LAB if the forage is ensiled with a humidity of more than 70% (Savoie and Jofriet. 2003). clostridium present in silage converts lactic acid and sugars into butyric acid. Concentrations of valeric acid and iso-valeric acid were not affected by wheat straw and microbial inoculation (P>0.05). Microbial inoculation of silage material increased the ratio of lactic acid to acetic acid (P<0.05). Numerous studies have shown the effect of LAB inoculation on increasing the lactic/acetic acid ratio in high moisture silage (Fang et al. 2022; Gallo et al. 2022).
3.4. Dry matter recovery and nutrient wastage
The results of dry matter recovery of silage after 60 days are reported in Table 5.
Table 5- The effect of wheat straw and SiloOne additive on the dry matter recovery and nutrient wastage of potato silage | |||||||
P-VALUE | SEM | Treatments** | Items* | ||||
PWLS | PLS | PWS | PS | ||||
0.0001 | 2.231 | 15.5 b | 38.28 a | 17.88 b | 41.84 a | Silo effluent | |
0.0001 | 1.673 | 3.72 b | 16.61 a | 4.31 b | 14.72 a | Oxidative loss | |
0.0001 | 1.666 | 80.78 a | 45.12 b | 77.8 a | 43.33 b | DM recovery | |
* DM is expressed as g/kg of as-fed diet, and all other items are expressed as g/kg DM. DM recovery, Dry matter recovery ** PS = Potato Silage; PWS = Potato-Wheat Straw Silage; PLS = Potato -Lactobacillus Silage; PWLS = Potato-Wheat Straw-Lactobacillus Silage. | |||||||
Starch swelling is due to the ability of starch to trap and retain water in its structure (Damodaran et al. 2018). Absorption of more than 50% by weight of water by potato starch causes its reversible swelling (Nelson. 2010). The results of the research of Kaur et al. (2002) show that the higher swelling of potato starch can be due to its larger grains. It has also been suggested that the higher inflation rate of potato starch may be due to the higher content of phosphate groups in amylopectin because repulsion between phosphate groups in adjacent chains can increase hydration by weakening the bond in the crystal domain (Galliard and Bowler. 1987). It seems that slicing potatoes by releasing the structure of starch grains causes the release of water during the silage and thus increases the synergy of potato starch. Silage effluents contain sugars, soluble nitrogen compounds, minerals, and fermentable acids, all of which have high nutritional value (McDonald et al. 2010). The addition of wheat straw as a moisture absorber to potato silages largely prevented the loss of silage fluid during silage (Table 5). Effluent loss and oxidative loss were significantly affected by wheat straw, so effluent loss and oxidative loss in wheat straw treatments (PWLS and PWS) were significantly reduced (p<0.01). Because straw has a high cell wall with air cavities in its underlying matrix, water is replaced in this empty space (Dehghan et al. 2012). The difference between silage weight on the first day and silage weight at the end of the silage period as dry matter recovery as weight percentage was expressed in Table 4, The results showed that the lowest rate of dry matter reduction was in silages containing wheat straw (p<0.01), Because straw has higher levels of NDF, adding it to potatoes increases NDF levels during ensiling (Table 1). Because nutrients such as soluble sugars are broken down faster than low-nutrients such as lignin, hemicellulose, and cellulose (Savoie and Jofriet. 2003), they are excreted in the effluent.
3.5. Aerobic stability
Table 6 - The effect of wheat straw and SiloOne additive on aerobic stability of potato silage | ||||||
P-VALUE | SEM | Treatments* | Items | |||
PWLS | PLS | PWS | PS | |||
0.0001 | 3.069 | 81.00 b | 88.00 b | 78.67 b | 179.33 a | Aerobic Stability (h) |
0.0001 | 0.482 | 11.06 a | 6.51 b | 7.46 b | 6.98 b | Aerobic loose (%) |
* PS = Potato Silage; PWS = Potato-Wheat Straw Silage; PLS = Potato -Lactobacillus Silage; PWLS = Potato-Wheat Straw-Lactobacillus Silage. | ||||||
Aerobic stability values were significantly higher in control silos (PS) (p<0.01). The control treatments had the highest concentration of propionic acid (p <0.05) and high amounts of acetic acid (Table 4). Propionic acid and acetic acid act as fungicides and inhibit the growth of yeasts and molds, which increases aerobic stability in silage (Mohammadzadeh et al, 2013). In treatments with wheat straw and bacterial additive (PWLS) we had the highest weight loss during the aerobic stability measurement period (p<0.01).
4.Conclusion
Based on the obtained data, the use of wheat straw in potato silage decreased the production rate of silage effluent and increased dry matter recovery. However, the fermentation quality of PWS was lower than PS. Of course, bacterial inoculation of potato silage with straw (PWLS) increased the quality of silage fermentation with high moisture. In general, the use of wheat straw and LAB can improve the quality of potato silage.
Acknowledgment
This study was supported by the University of Tabriz. Special thanks are Dr. Hamid Paya and Dr. Saeed Narimani Garajeh for all they did during Research.
References
Amer S., Hassanat F., Berthiaume R., Seguin P. and Mustaf A.F. (2012). Effects of water soluble carbohydrate content on ensiling characteristics, chemical composition and in vitro gas production of forage millet and forage sorghum silages. Animal Feed Science and Technology, 177, 23–29.
AOAC. (2005) Association of Official Analytical Chemists, 1990. Official methodss of analysis, 14th Edition. AOAC, Washington, DC.
Babaeinasab, Y., Rouzbehan, Y., Fazaeli, H. and Rezaei, J. (2015). Chemical composition, silage fermentation characteristics, and in vitro ruminal fermentation parameters of potato-wheat straw silage treated with molasses and lactic acid bacteria and corn silage. J. Anim. Sci. 93:4377–4386.
Barrell P.J., Meiyalaghan S., Jacobs J.M. and Conner A.J. (2013). Applications of biotechnology and genomics in potato improvement. Plant Biotechnology J., 11(8):907-20
Borreani G., Tabacco E., Schmidt R.J., Holmes B.J. and Muck R.E.. 2018. Silage review: Factors affecting dry matter and quality losses in silages. J Dairy Science, 101, 5, 3952-3979
Bradshaw, L., MacGregor, S. and Olsen, T. (2002). Potato by-product feeding in the Pacific Northwest. Vet. Clin. North Am.: Food Anim. Pract., 18 (2): 339-347.
Chung H. J. and Liu Q. (2010). Molecular structure and physicochemical properties of potato and bean starches as affected by gamma-irradiatio. International Journal of Biological Macromolecules, 47(2); 214-222.
Damodaran S., Parkin K.L. and Fennema O.R. (2018). Fennema's Food Chemistry-CRC Press (2018) - 5th. P 17–83.
da Silva Figueiró C., Trojaner M.R., Calcagno, C.I.W. et al.( 2022). Rheological and structural characterization of cassava starches foam with low and high amylose contents. J Polym Res. 29, 30.
Dehghan M., Tahmasebi R., Dayani O. and Kezre A. (2012). Determination of Physical, Chemical and Digestibility of some Agricultural by-products. Iranian Journal of Animal Science Research. 3, 4. 412-421.
Driehuis F. and wikselaar V.(1999). The prevention of alcoholic fermentation in high dry matter grass silage. Animal Science and Health, P.O. Box 65, 8200 AB, Lelystad, THE NETHERLANDS.
Fang D., Dong Z.,Wang D., Li B., Shi P., Yan J., Zhuang D., Shao T. and Wang W. (2022). Evaluating the fermentation quality and bacterial community of high-moisture whole-plant quinoa silage ensiled with different additives. J Applied Microbiology.
FAOSTAT. [(accessed on 7 March 2022)]; Available online:
http://www.fao.org/faostat/en/#rankings/countries_by_commodity
Filya I. (2003). The effect of Lactobacillus buchneri and Lactobacillus plantarum on the fermentation, aerobic stability, and ruminal degradability of low dry matter corn and sorghum silages. J Dairy Sci 86: 3575-3581.
Gallo A. Fancello F., Ghilardelli F., Zara S. and Spanghero M. (2022). Effects of several commercial or pure lactic acid bacteria inoculants on fermentation and mycotoxin levels in high-moisture corn silage. Animal Feed Science and Technology. 286, 115256.
Halliday L. (2015). Ensiling potatoes. Prince Edward Island, Canada,. Department of Agriculture, Fisheries and Aquaculture.
Jane J., Chen Y.Y., Lee L.F., McPherson A.E., Wong K.S., Radosavjevic M. and Kasemsuwan T. (1999). Effects of Amylopectin Branch Chain Length and Amylose Content on the Gelatinization and Pasting Properties of Starch. Cereal Chem. 76 (1999) 629–637.
Kaur L., Singh N., Sodhi N.S., Gujral H.Singh. (2002). Some properties of potatoes and their starches I. Cooking, textural and rheological properties of potatoes. Food chemistry, 79(2): 177-181.
Kilic, A. )1986(. Silo Feed (Instruction, Education and Application Proposals). Bilgehan press, Izmir,: 327.
Khorvash M., Mohammadzadeh H. and Yekdanegi M.B. (2014). Management of silage production and Utilization. Arkan Danesh Publications. Esfahan. IRAN.
Lee S.Y., Lee K.Y. and Lee H.G. (2018). Effect of different pH conditions on the in vitro digestibility and physicochemical properties of citric acid-treated potato starch. International Journal of Biological Macromolecules. V107, P A, Pages 1235-1241.
Lindahl I., Davis R.E. and Ellis N.R. (1946). Effect of temperature and length of storage on ensilage made from cooked white potatoes. J. Anim. Sci. 5:279–28
McDonald P., Edwards R.A., Greenhalgh J.F.D., Morgan C.A., Sinclair L.A. and Wilkinson R.G. (2010). Animal Nutrition, 7th Edition. NO 27,505.
McDonald P., Henderson N. and Heron S. (1991). The biochemistry of silage, 2nd edn Chalcombe Publications.
Mercier P., Yerushalami L., Rouleau D. and Dochania D. (1992). Kinetics of lactic acid fermentations on glucose and com by Lactobacillus amylophilus. J Chem Technol Biotechnol 1992;55:111-21.
Mohammadzadeh H., Khorvash M. and Ghorbani G.h. (2013). Effects of bacterial inoculant containing homo and heterolactic lactobacillus on fermentation ofcorn silage and performances of Holstein dairy cattle. Journal of Animal Science Research, Volume 42 Number 1.
Monteils V., Jurjanz Colin-Schoellen O., Blanchart G. and LaurentKinetics of ruminal degradation of wheat and potato starches in total mixed rations. J Animal Science, 80, 1, 235–241.
Narita J., Nakahara S., Fukuda H. and Kondo A. (2004). Efficient production of L-(+)-lactic acid from raw starch by Streptococcus bovis 148. J. Biosci. Bioeng.97:423-425.
Nelson M.L. (2010). Utilization and application of wet potato processing coproducts for finishing cattle. Journal of Animal Science, 88,133-142.
Nishino N., Yoshida M., Shiota H. and Sakaguchi E. (2003). Accumulation of 1, 2 propanediol and enhancement of aerobic stability in whole crop maize silage inoculated with Lactobacillus buchneri. J Appl Microbiol 94: 800-807.
Nkosi B.D., Meeske R., van der Merwe H.J. and Groenewald I.B. (2010). Effects of homofermentative and heterofermentative bacterial silage inoculants on potato hash silage fermentation and digestibility in rams. j.anifeedsci.2010.03.008.
Okine A., Hanada M., Aibibula Y. and Okamoto M. (2005). Ensiling of potato pulp with or without bacterial inoculants and its effect on fermentation quality, nutrient composition and nutritive value. Animal Feed Science and Technology, 121, (3-4), pp. 329-343.
Pazhouhandeh M, Karvan G. and Razavi A.S. (2017). A review on potato genetic engineering researches yet. Genetic Engineering and Biosafety, Volume 6, Number 1, 175-188
Peshin A. (2001). Characterisation of starch isolated from potato tubers (Solanum tuberosum L.). Journal of Food Science and Technology—Mysore, 38, 447–4.
Pringojin I., Fallik E., Qat Y., Ajalin H., Allam M.M., Ezzat M. Al Masri M. and Bader M. (2005). Middle East Regional Agriculturel Program Survey on Postharvest Losses of Tomato Fruit (Lycopersicon Esculentum) and Table Grapes (Vitis Vinifera).
, , , and Amylolytic bacterial lactic acid fermentation - a review. Biotechnol Adv 26: 22– 34.
Rocha T.D.S., Carneiro A.P.D.A. and Franco C.M.L. (2010). Effect of enzymatic hydrolysis on some physicochemical properties of root and tuber granular starches. Ciência e Tecnol Aliment. 30: 544-551.
Sauter E. A., Hinman D. D. and Howes. (1979). Energy losses from potato processing waste during laboratory storage. J. Anim. Sci. 49:607–612.
Savoie P. and J C. Jofriet. (2003). Silage strorage. Pages 405–467 in Silage Science and Technology (Agronomy Series No. 42). D. R. Buxton, R. E. Muck, and H. J. Harrison, ed. American Society of Agronomy, Madison, WI.
Svihus B., Uhlen A.K and Harstad O.M.(2005). Effect of starch granule structure, associated components and processing on nutritive value of cereal starch: A review. Animal Feed Science and Technology. 122:303-320.
Van Soest, P.V., Robertson J. B. and Lewis B. A. (1991). Methods for dietary fiber, neutral detergent fiber, and nonstarch polysaccharides in relation to animal nutrition. J. Dairy Sci., 74(10):3583-3597.
Wang M., Wang H., Zheng H., Uhrin D., Richard J. Dewhurst and Rainer Roehe. (2021). Comparison of HPLC and NMR for quantifcation of the main volatile fatty acids in rumen digesta. Sci Rep,11, 24337 .
Influence of ultrasound and microwave treatments on the structural and thermal properties of normal maize starch and potato starch: A comparative study, Food Chemistry, 10.1016/j.foodchem.2021.131990, 377, (131990).
Xia C., Zhong L,. Wang J., Zhang L., Chen X., Ji H., Ma S. Dong W., Ye X., Huang Y., Li Z. and Cui Z. (2021). Structural and digestion properties of potato starch modified using an efficient starch branching enzyme AqGBE, International Journal of Biological Macromolecules. 10.1016/j.ijbiomac.2021.06.135, 184, (551-557).
Yusupha M., Testera R .F., Ansella R. and Snapeb C. E. (2003). Composition and properties of starches extracted from tubers of different potato varieties grown under the same environmental conditions. Food Chemistry 82 (2003) 283–289.
Zhang W. W., Zhang Y. G. and Z. Liu. (2012). Effect of different absorbents on fermentation quality of wet potato pulp. Journal of Animal and Veterinary Advances, 22: 4230- 4235.